![background image](http://html1.mh-extra.com/html/scag-power-equipment/stt61v-27ch-ss/stt61v-27ch-ss_operators-manual_1205884039.webp)
Section 7
35
Electric storage battery fluid contains
sulfuric acid which is POISON and can
cause SEVERE CHEMICAL BURNS. Avoid
contact of fluid with eyes, skin, or clothing.
Use proper protective gear when handling
batteries. DO NOT tip any battery beyond
45° angle in any direction. If fluid contact
does occur, follow first aid suggestions
below.
BATTERY ELECTROLYTE FIRST AID
EXTERNAL CONTACT — Flush with water.
EYES — Flush with water for at least 15
minutes and get medical attention
immediately.
INTERNAL — Drink large quantities of water.
Follow with Milk Of Magnesia, beaten egg, or
vegetable oil. Get medical attention
immediately. In case of internal contact, DO
NOT give fluids that would induce vomiting.
WARNING:
1. Unhook the clamps securing the air cleaner cover to
the air filter canister. Remove the air cleaner cover
and set aside.
2. Remove the air cleaner and inspect.
3. Clean or replace the air cleaner as recommended by
the engine manufacturer.
7.7 BATTERY
Lead-acid batteries produce flammable and
explosive gases. To avoid personal injury
when checking, testing or charging
batteries, DO NOT use smoking materials
near batteries. Keep arcs, sparks and
flames away from batteries. Provide proper
ventilation and wear safety glasses.
WARNING:
Charging the Battery
Refer to the battery charger’s manual for specific
instructions.
Under normal conditions the engine’s alternator will have
no problem keeping a charge on the battery. If the
battery has been completely discharged for a long period
of time, the alternator may not be able to recharge the
battery, and a battery charger will be required.
DO NOT charge a frozen battery. It may explode and
cause injury. Let the battery warm before attaching a
charger.
Whenever possible, remove the battery from the mower
before charging and make sure the electrolyte covers the
plates in all cells.
WARNING:
BATTERIES PRODUCE EXPLOSIVE
GASES. Charge the battery in a well
ventilated space so gases produced while
charging can dissipate.
Charging rates between 3 and 50 amperes are
satisfactory if excessive gassing or spewing of
electrolyte does not occur or the battery does not feel
excessively hot (over 125°F). If spewing or gassing
occurs or the temperature exceeds 125°F, the charging
rate must be reduced or temporarily stopped to permit
cooling.
C. Jump Starting
1. The booster battery must be a 12 volt type. If a
vehicle is used for jump starting, it must have a
negative ground system.
2. When connecting the jumper cables, connect the
positive cable to the positive battery post, then
connect the negative cable to the negative battery
post.