TF 200.01.0016_ENG
14
4.3 Operating the product
NOTE!
It is important that you are familiar with the use of the hoist and its functions, and that it
works properly. So for the best possible safety, all users of the hoist must read this user
manual before using the hoist.
For the All-in-One you can use any of Ropox Domino slings.
4.3.1 Operating instructions
-
Check that the emergency stop has been released. If not, turn the button clockwise until release.
-
The hoist is operated by means of the hand control unit. The two upper buttons control the lifting/lowering
movement, whereas the two lower buttons control the leg spreading facility. It is not possible to use two
functions simultaneously.
-
Check that the sling provided is correct for the lifting operation to be performed. This applies to size as well
as shape. Further information about the cho
ice of slings will be found in ”Domino Slings User manual”.
-
The battery should be recharged regularly, to ensure that the hoist is always available (e.g. every night).
4.3.2 Emergency situation
Emergency stop and emergency lowering (electrical and mechanical) should be used in emergencies only.
Should it be necessary to activate the emergency functions, contact the distributor before using the hoist again.
4.4
Recharging the battery
-
The battery
must
be recharged after approx. 60 lifting operations
– i.e. at 50% battery capacity. In case of
continued use you will hear an acoustic signal. The battery can still be used, but it will affect is recharging
capability.
-
We recommend charging as soon as the hoist is not being used for a longer period of time, e.g. every night.
The battery cannot be over-
charged and it is only ”healthy” for the battery to be recharged often as it
increases the battery life.
-
Charging is made directly in the control unit by means of the mains cable provided. Insert the cable into the
wall outlet and the control unit, see drawing page 12, and switch on power. The hoist cannot be used when
connected to mains voltage.
-
A green light on the control unit indicates connection to mains voltage. A yellow light indicates that the
battery is being recharged.
-
When the battery has been fully charged, the yellow light will be out.
-
Full recharging takes 4-5 hours.
-
If charging is made via a wall-mounted charging station (optional) a battery may be constantly charged in
the station. The batteries may be easily switched by means of the snap system on top of the battery box.
NOTE!
In case of erroneous operation of the hand control unit (e.g. too quick change of
direction) the hoist does not react. Let go of the push button
– wait a few seconds and
press again.
Warning!
The product should always be able to travel the full range of actuation without colliding
with objects. Failing to do so will compromise the product stability.
Special care should be taken in ensuring that no children or adults are sited under the
product as severer injury from entrapment may occur.
