RHINOCEROS XN08, Operation & Maintenance Manual

Page: 34 / 52

34
1. Manually loosen the drain plug at bottom of
oil-water separator.
2. After the draining, manually tighten the drain to
ensure no leakage of oil or air.
Caution: after the draining, make sure air is drained out
of fuel system to make sure the engine could start up
normally.
Electrical system - battery
I. Check the battery electrolyte level and the terminals.
Caution:
gas inside of battery may explode it. Therefore, keep any spark and flame away from battery.
Use a flashlight to check the electrolyte level. In addition, the sulphuric acid in battery electrolyte is as toxic as to
burn your skin or your cloth holes or to blind your eyes. . .
Therefore, take the following methods to avoid any rick:
1. Refilling of battery should be done at well-ventilated site.
2. Put on goggles and plastic gloves.
3. Care must be taken not to spray out the electrolyte.
4. Use the proper measures to assist battery startup.
If touched with acid:
1. Rinse the skin
2. Use the soda or the lime to neutralize the acid.
3. Rinse eyes for 10 - l5 min and then go to doctor.
Caution:
a. Always firstly disconnect the battery clips (-) away from the ground and then lastly connect it.
b. Always keep the terminals at top to battery and the breather clean, to avoid the battery from discharging.
Check if the battery terminal is loosened or rusted. Coat the terminals with vaseline to avoid any corrosion.