ProFire SDBOCN, Owner'S Manual, Page: 4 / 20

4
Well ventilated space, NOT in a building, gar-
age, or any other enclosed area. It must be out
of reach of children. A dust cap MUST be used
whenever the tank is disconnected from the
grill. When grill is not in use, close propane tank
cylinder valve.
When the propane tank is connected, the grill
must be stored outdoors in a well ventilated
space, not in a building, garage or any other
enclosed area. Always close the propane tank
before disconnecting it from the grill or when
the grill is not in use.
If the grill is going to be stored for winter or for
an extended period of time, we suggest you fol-
low these steps:
-The burner should be cleaned and coated
lightly with cooking oil to prevent from rusting.
-The venture openings should be covered with
aluminum foil to prevent small insects from
entering the opening during storage and must
be removed before using.
-The grill should be covered if it is left outdoors.
Grill covers are available as an accessory.
-Follow the cleaning procedures.
Hose and Regulator
The pressure regulator and hose assembly sup-
plied with the appliance must be used. This
pressure regulator is preset for an outlet pres-
sure of 11 inches (27.9 cm) water column.
Therefore, this pressure regulator MUST be
used with your Scottsdale Grill. Before each
use of the grill inspect the hose for wear, crack-
ing and examine for any cuts. If any these con-
ditions exist,
do not use, purchase a new hose
and regulator. If a replacement is needed, refer
to the parts list for the part number and contact
the dealer where your grill was purchased. Re-
fer to
“Connecting the Cylinder to the Grill”
for details of hooking up your regulator to the
LP gas cylinder. Make sure a leak test is per-
formed every time you have your LP gas cylin-
der refilled, and visibly inspect for excessive
wear and damage on a regular basis. Always
follow the directions for the “Leak Test”.
Natural Gas
Your grill may be converted to natural gas by
replacing the LP Valve with the appropriate Nat-
ural Gas Valve. (Part #HHVLV32-SD). A con-
version is only be made by an authorized
Phoenix Grill dealer or local gas utility in ac-
cordance with all applicable codes.
CAUTION:
Any additions, changes, or conversions re-
quired in order for the appliance to satisfactorily
meet the application needs must be made by a
Scottsdale dealer or local gas utility using facto-
ry specified and approved parts. Always re-
member to shut gas off at gas connection when
grill is not in use.
SAFETY
Leak Test
Check for leaks before lighting the grill for the
first time, after storing the grill between seasons
and after refilling the propane cylinder.
Take your grill outdoors into a well ventilat-
ed area. Do not use or permit sources of ig-
nition in the area during this test, this in-
cludes smoking. Use only a soap and water
solution to test for leaks.
Leak Test Check List
-Tank valve (all over) including area that
screws into the tank and the welds.
-Regulator fitting
-Hose connections
-Valves
Mandatory Leak Test
1. Have propane tank filled with propane gas
only by a reputable propane gas dealer.
2. Attach regulator fitting to tank valve.
3. Tighten regulator fitting securely.
4. Turn the control knobs to the right, clockwise.
This is the “OFF” position.
5. Make a solution of half liquid detergent and
half water.
6. Turn gas supply
“ON” at the tank valve
(counter clockwise).
7. Brush soapy mixture on all connections listed
in the
Leak Test Check List.
8. Observe each place for bubbles caused by
leaks.
9. Tighten any leaking connections, if possible.
If leak cannot be stopped,
DO NOT USE
THE GRILL. Order new parts from an
authorized Scottsdale dealer. Do not use the
grill until after the new parts are installed.
After installing new parts, perform complete
leak test.
10. Turn gas supply
“OFF” at the tank valve.