Operation
40
8.
Storage & Exercise
When you are finished using the generator, you must:
o
Disconnect all loads
o
Allow generator to completely cool down
o
Store the generator properly
o
Plan on exercising the engine regularly unless the generator is prepared for long-term storage.
Detailed instructions are provided below.
Disconnect loads
When you are finished using the generator:
o
Make sure all devices that were connected to the generator’s outlets
have been disconnected.
Cool engine before
storing
Let engine cool for at least five minutes before storing.
A hot engine can
be a fire hazard.
Choose a storage
location
Store the generator in a location that is:
o
Clean and dry
o
Away from sources of heat, open flames, sparks, or pilot lights, even
if the generator’s fuel tank is empty. Residual fuel in the tank could
ignite.
o
Away from extreme high or low temperatures.
Prevent accidental
starting
Remove spark plug
(s) in order to ensure the generator cannot be started
accidentally in a storage location or by untrained persons.
Exercise generator
every 4 weeks
The generator should be exercised regularly.
At least every four weeks, start the engine and let it run for 10 to 15 minutes
with a small load plugged in, such as a lamp or fan.
Monthly exercising of the generator will:
o
Dry out any moisture that has accumulated in the windings. If left,
this moisture can cause corrosion in the winding.
o
Ensure that the unit is operating properly should it be needed in an
emergency.
Perform regular
maintenance
Perform periodic maintenance
as directed in this manual to keep the
generator in safe working condition.
Storage Chart
You must prepare the engine for long term storage
to prevent gum
deposits from forming and causing malfunction of the engine.
* Use gasoline stabilizers that are formulated to extend storage life.
STORAGE TIME
RECOMMENDED SERVICE PROCEDURE TO
PREVENT HARD STARTING
Less than 1 month
No preparation required.
1 to 2 months
Fill with fresh gasoline and add gasoline stabilizer*.
2 months to 1 year
Fill with fresh gasoline and add gasoline stabilizer*.
Drain the carburetor.
1 year or more
Drain the fuel tank and carburetor.
Change the engine oil and lubricate the cylinder.
