PolyCool ICESLHPLYA24L User Manual Download

Page: 8 / 17

PRSL Series IV Slushie Machine

E&OE

Adjusting Tank Temperature

Note

: The factory settings should be suitable for most uses. Adjust the thermostats only if required. If you

adjust the thermostat, it is recommended to monitor the change

– is the solution at the right temperature? –

and adjust until the desired result is reached.

Each tank has a thermostat for setting the
“coldness” of the drink solution. Depending on
ambient temperatures (climate or operating
environment temperature), drink solution etc, the
coldness of the tanks may need adjusting for the
desired coldness and consistency of slush ice and
coldness of juice etc.

The tank thermostats (

) are located on the control

panel side of the machine, behind the plastic guard
(

). Use a Phillips head screwdriver to remove the

screw (

) fastening the guard. Gently pull the guard

out from the bottom edge until it unhooks from the
machine. The lower control is for the right-side tank,
the middle control is for the left-side tank on 2-tank
models or the middle tank for 3-tank models, the
upper control is for the left-side tank on 3-tank models. Left to right is taken when looking at the front of the
machine.

Rotate the thermostat knob as required

– rotate right (clockwise) to increase coldness; rotate left (anti-

clockwise) to reduce coldness. It is recommended to not change the thermostat setting too much in a single
adjustment

– make small changes and monitor the result. When finished adjusting, re-install the plastic

guard.

Filling the Tanks

Ensure that the drink solution is less than 35°C (95°F) when filling the tanks otherwise machine
damage may result.

• Always mix the drink solution so that is a minimum of 13% sugar (ratio

approximately 6.5 parts water to 1 part sugar), otherwise the consistency of slush ice will be

incorrect and

damage to machine may result. • Never allow the level of the drink solution to remain below the

minimum level or above the maximum level as machine damage may result.

Failure to carry out the

procedures correctly may result in making the product warranty void

1. Thoroughly mix the drink solution according to its instruction. Mix in a

container that is clean and suitable for handling food and drink for human
consumption.

2. Switch OFF the slush or juice mode switch and beater for the tank before

refilling. If you are filling all tanks, turn OFF the compressor

using the “master”

switch.

3. Switch OFF the tank lights.

4. Unplug and remove the tank cover.

5. Carefully pour the mixture into the tank. Do not fill to less than the

“MIN LEVEL” indicator or over the “MAX LEVEL” indicators on the
front of the tank.

6. When finished filling, place the tank cover in position and re-connect

the cable. Reconnect the machine to the electricity supply if
previously unplugged. Switch ON the slush or juice mode switch and
beater for the tank

or at the “master” switch. Switch ON the tank

lights.

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

POL

YCOOL

Summary of Contents for ICESLHPLYA24L


















Search results

Summary of Contents for ICESLHPLYA24L

Reviews:

Related manuals for ICESLHPLYA24L

Brands by name

Popular brands

PolyCool ICESLHPLYA24L, User Manual

Search results

Summary of Contents for ICESLHPLYA24L

Reviews:

Related manuals for ICESLHPLYA24L

Brands by name

Popular brands