Piper Aircraft Corporation Cherokee 140 PA-28-140, Service Manual

Page: 664 / 1024

PIPER CHEROKEE SERVICE MANUAL
01/31/08 III - INSPECTION
3H17
TABLE III-I - INSPECTION REPORT - PA-28-140/150/160/180/235
Refer to Notes 1, 2, 3, and 4 before performing the following inspections.
Inspection
NATURE OF INSPECTION Interval (Hrs)
50 100
B. ENGINE GROUP (CONT.)
34. Inspect throttle, carburetor heat, mixture, and propeller governor controls
for security, travel and operating condition. (See Notes 27 & 29.) ....................... O
35. Inspect exhaust stacks, connections and gaskets per Exhaust System Inspection.
(See Special Inspections, Procedures.) Replace gaskets as required .................... O O
36. Inspect muffler, heat exchange and baffles per Exhaust System Inspection.
(See Special Inspections, Procedures.) ................................................................. O O
37. Inspect breather tube for obstructions and security .............................................. O
38. Inspect crankcase for cracks, leaks, and security of seam bolts ........................... O
39. Inspect engine mounts for cracks and loose mounting ......................................... O
40. Inspect all engine baffles ....................................................................................... O
41. Inspect all wiring connected to engine and accessories ........................................ O O
42. Inspect rubber engine mount bushings for deterioration. (Replace as required.) . O
43. Inspect firewall seals ............................................................................................. O
44. Lubricate alternator idler pulley; remove front grease seal and add grease
per Lubrication Chart, Section II. Disregard if sealed bearing is installed ........... O
45. Inspect condition of alternator and starter ............................................................ O
46. Inspect security of alternator and mounting .......................................................... O
47. Inspect condition and tension of alternator drive belt.
(See Checking Generator and Alternator Belt Tension, Section XI.) ................... O
48. If installed, inspect condition of A/C compressor belt and tension.
(See Adjustment of Drive Belt Tension, Section XIV, Paragraph 14-23.) ............ O
49. If installed, check A/C compressor oil level. (See Note 12.) ................................ O
50. If installed, inspect A/C compressor clutch security and wiring.
(See Note 13.) ....................................................................................................... O
51. If installed, inspect A/C compressor mounting for cracks, corrosion,
and security ........................................................................................................... O
52. Check fluid in brake reservoir. Fill as required ..................................................... O O
53. Inspect and lubricate all controls per Lubrication Chart, Section II ..................... O
54. Install engine cowling ........................................................................................... O O
C. CABIN AND COCKPIT GROUP
1. Inspect cabin door latch and hinges, and windows, for damage,
operation and security ........................................................................................... O
2. Inspect windows for scratches, crazing, and condition ......................................... O
3. Check window and door seals for deterioration, cracks, and voids ...................... O
4. Inspect upholstery for tears ................................................................................... O
5. Inspect seats and seat belts for security of brackets and bolts.
(See Note 32 and Restraint System, Inspection, Section XIV.) ............................ O
6. Inspect trim control operation ............................................................................... O
7. Inspect condition and operation of rudder pedals and
rudder bar assembly. (See Note 28.) ..................................................................... O