TROUBLESHOOTING LOGIC DIAGRAM
Page: 28
Reproductions or translations, even parrtial, are forbidden without the written consent of Peugeot Motocycles
Range test:
Under the following conditions:
Scooter charged 100%, run it within a maximum of 8 hours after the end of charging
The route should be covered without interruption, on flat roads with a minimum of stops and until the
reserve light
comes on (the reserve you to cover another 5 km)
Electrolyte
leak on one
of the cells
With power gauge under
25 % and the cells
disconnected,
check the voltage of each
cell.
The difference in voltage
between each cell should
not be over 0.8 V.
Ranged stated by customer
Over 20 km, check:
Under 20 km with motor cut-out,
check:
Electrolyte
level in cells
Tyre
pressures
2.5 bar
If level is
incorrect, carry
out
battery
maintenance
Carry out a
range check
Brake
adjustment:
20 mm play
on brake lever
If the difference in
voltage is under
0.8 V, the battery
is OK
If the difference in
voltage is over 0.8
V, the weakest
battery must be
changed
Carry out a range check.
If range is still low, discharge the 3 cells using the
discharge apparatus and compare the discharge times of
each cell.
If a cell has a discharge time far below that of the others
change it.
