Omcan CD-GR-1500, Instruction Manual

Page: 7 / 28

7
Installation
Operation
installed in the supply line.
DRAINAGE CONNECTION
Outflow is accomplished by gravity (natural flow) in the CD-GR-1500. The outlet hose should be connected
either directly to a floor drain or drain which must not be higher than the level of the outlet at the rear of the
machine. An open drain connection or one to a vented drain pipe is recommended.
ELECTRICAL CONNECTION
The dishwasher operates under specific voltage as noted on the attached Technical Specifications label.
Note: A licensed electrician should be used for the connection according to local codes.
A 208 or 230 volt, one (1) phase, 60hz, 50A power circuit is required as unit draws 43A using 2 wire plus
ground. No neutral (115 volt service) is required. The ground line must be connected at the junction block.
Prepare power line with about 35” ( 95 CM ) of wire with the shielding removed. Install either a ¾” connector or
½” with ½” x ¾” bushings.
Open front control panel by removing two nuts and open inside cover by removing 4 nuts holding cover.
Insert power line in appropriate ¾” hole in rear panel, or if suitable, a ½” connector with bushings can be used,
mount connector, and feed wire to front control box terminals. Mounting posts are provided to hold wires with
“Tye Wraps”. Allow sufficient slack at panel end to allow wire to move when control panel is repositioned to
closed.
Connect power line to junction block. Be sure connections are tight.
Close control panel cover with the 4 nuts, and close the front panel with the two acorn nuts.
After installation, the dishwasher should be cleaned thoroughly before putting into operation.
INSTRUCTIONS FOR REGULAR OPERATION
The appliance is intended to clean dishes, cups, glasses, silver, etc. Be sure the items placed to be washed
are suitable for dishwashing. Silver should be cleaned of heavy food residues, if not washed right after use.
This machine is not intended for use with items which were used with acids, mineral oil, grease, gasoline or
colors.