Napoleon GD25-N, Installation And Operation Instructions Manual

Page: 15 / 24

15
WS-415-099 /03.16.99
FIGURE 31
DOOR
STEEL LIP
OPTIONAL GLOWING EMBER INST OPTIONAL GLOWING EMBER INST OPTIONAL GLOWING EMBER INST OPTIONAL GLOWING EMBER INST OPTIONAL GLOWING EMBER INSTALLA ALLA ALLA ALLA ALLATION TION TION TION TION
Tear the embers into pieces and place beneath the front log covering all of the burner area beneath and in front of the
hollowed out section of the log. Care should be taken to shred the embers into thin, small irregular pieces as only the
exposed edges of the fibre hairs will glow.
THE EMBER MATERIAL WILL ONLY GLOW WHEN EXPOSED TO DIRECT FLAME; HOWEVER, CARE SHOULD BE TAKEN
TO NOT BLOCK THE BURNER PORTS.
Blocked burner ports can cause an incorrect flame pattern, carbon deposits and delayed ignition. PHAZER TM logs glow
when exposed to direct flame. Use only certified "glowing embers" and PHAZER
TM
logs available from your Napoleon / Wolf Steel Ltd. dealer.
DOOR, LOUVRE AND TRIM REMOV DOOR, LOUVRE AND TRIM REMOV DOOR, LOUVRE AND TRIM REMOV DOOR, LOUVRE AND TRIM REMOV DOOR, LOUVRE AND TRIM REMOVAL & INST AL & INST AL & INST AL & INST AL & INSTALLA ALLA ALLA ALLA ALLATION TION TION TION TION
ENSURE THAT THE DOOR IS PROPERLY CLIPPED ONTO THE
STEEL LIP TO PREVENT OVERHEATING, GLASS BREAKAGE AND/
OR DISCOLOURATION OF THE UPPER TRIM.
DOOR REMOVAL:
Both top and bottom door trim must be
removed prior to door removal. Lift up the top trim and
unhook from the door. The bottom trim may be pulled off
and lifted out of the bottom door sill.
FIGURE 30 .
Remove the five screws securing the sides and bottom of
the door. Lift up and out.
DOOR AND TRIM INSTALLATION:
When re-installing, re-
tighten screws snugly. DO NOT OVER-TIGHTEN.
Hang the door side trim onto each door side with the
notches towards the centre of the unit. The top and bottom
door trim may be installed next. Attach magnets to the top
and bottom door trim approximately 4" from either end.
Lift up the top trim and hook over the top of the door. The
bottom trim is inserted into the bottom door sill. Push in to
engage the magnets. Centre both side trims.
LOUVRES:
The louvre assemblies are installed as illus-
trated in FIGURE 31 . Optional arched door facias are
available at your local Napoleon/ Wolf Steel dealer.
FIGURE 29
FIGURE 30