3
•
Never
connect an unregulated LP gas tank to
your gas grill. The gas Regulator assembly
supplied with your gas grill is adjusted to have
an outlet pressure of 11" water column (W.C.)
for connection to an LP gas tank.
•
Only use the Regulator and Hose Assembly
supplied with your gas grill. Replacement
Regulators and Hose Assemblies must be
those specified by manufacturer.
•
Have your LP gas tank filled by a reputable
propane gas dealer and visually inspected and
re-qualified at each filling.
•
Never fill the gas tank beyond 80% full.
Have your propane gas dealer check the
release valve after every filling to ensure that it
remains free of defects.
•
Always keep LP gas tanks in upright position.
•
Do not store (or use) gasoline or other flammable
vapors and liquids in the vicinity of this gas grill.
•
An LP gas tank that is not connected for use must
NOT be stored on bottom shelf inside cabinet or in
the vicinity of this or any other gas grill.
•
Do not subject the LP gas tank to excessive heat.
•
Never store an LP gas tank indoors. If you
store your gas grill in the garage or other
indoor location,
always
disconnect the LP gas
tank first, store it safely outside.
•
LP gas tanks must be stored outdoors in a
well-ventilated area and out of the reach of
children. Disconnected LP gas tanks
must not be stored in a building, garage or
any other enclosed area.
•
When your gas grill is not in use the gas
must be turned off at the LP gas tank.
Proper Placement and Clearance of Grill
Never
use your gas grill in a garage, porch, shed,
breezeway or any other enclosed area. Your gas grill is
to be used
outdoors only
, at least 24 inches from the
back and side of any combustible surface. Your
gas grill should not be placed under any surface
that will burn. Do not obstruct the flow of ventilation
and combustion air around the gas grill housing.
This outdoor gas grill is not intended to be installed in
or on recreational vehicles and/or boats.
The LP gas tank has a Shut Off Valve,
terminating in an LP gas supply tank valve
outlet, that is compatible with a Type 1 tank
connection device. The LP gas tank must
also have a safety relief device that has a
direct communication with the vapor space of
the tank.
The tank supply system must be arranged
for vapor withdrawal.
The LP gas tank used must have a collar
to protect the tank valve.
1.
2.
3.
•
The Regulator and Hose assembly must be
inspected before each use of the grill. If there
is excessive abrasion or wear or if the hose
is cut, it must be replaced prior to the grill
being used again.
•
Keep the gas Regulator Hose away from hot
grill surfaces and dripping grease. Avoid
unnecessary twisting of hose. Visually inspect
hose prior to each use for cuts, cracks,
excessive wear or other damage. If the Hose
appears damaged do not use the gas grill,
call our Grill Information Center for a
replacement, at 1-800-770-9769.
•
Never
light your gas grill with the Lid closed
or before checking to insure the Burner Tubes
are fully seated over the Gas Valve Orifices.
•
Never
allow children to operate your grill. Do
not allow children to play near your grill.
Failure to comply with these instructions
could result in a fire or explosion that
could cause serious bodily injury, death,
or property damage.
WARNING
!
A strong gas smell, or the hissing sound of
gas indicates a serious problem with your
gas grill or the LP gas tank. Failure to
immediately follow the steps listed below
could result in a fire or explosion that could
cause serious bodily injury, death, or prop-
erty damage.
NOTE:
The normal flow of gas through the
Regulator and Hose Assembly can create a
humming sound. A low volume of sound is
perfectly normal and will not interfere with
operation of the grill. If humming sound is
loud and excessive you may need to purge
air from the gas line or reset the Regulator
excess gas flow device. This purging proce-
dure should be done every time a new LP
gas tank is connected to your grill. For help
call the Grill Information Center.
Grill Information Center, 8:00am-4:30pm
CST, Monday through Friday at:
1-800-770-9769
•
Shut off gas supply to the gas grill.
•
Turn the Control Knobs to OFF position.
•
Put out any flame with a Class B fire
extinguisher.
•
Open Grill Lid.
•
Get away from the LP gas tank.
•
Do not try to fix the problem yourself.
•
If odor continues or you have a fire you cannot
extinguish, call your fire department. Do not call
near the LP gas tank because your telephone is
an electrical device and could create a spark
resulting in fire and/or explosion.
!
WARNING