7
Maintenance
TDS Adjustment
*
Although the rejected water has high concentration of salts, it is absolutely clean and free of
impurities like chlorine, dirt, sand, etc. which are present in raw water. This rejected water usually
goes down the drain but if required, can be used for gardening purposes. It has high concentration
of salts and minerals which accelerate plant growth. Rejected water can also be used for cleaning
purposes, i.e. utensils cleaning, mopping, etc.
Recommended Usage of Reject Water
n
n
n
n
n
n
n
Switch on the power supply
Allow the storage tank to fill to the maximum level**
Switch off the power supply
Open the drain plug present at the bottom of the storage tank and drain the tank to
remove residual dust particles present in the pipes and storage tank
Plug back the drain plug
Switch on the power supply
Purifier is ready to use
We recommend keeping the TDS at lowest but not below 50mg/l.
Starting Up the Purifier
8
n
n
n
n
n
Storage tank must be drained once in 2
Replace RO membrane once in a year
weeks. To do so, switch off the power supply.
Replace UF membrane once in a year
Open the drain plug present at the bottom of
the storage tank and drain the tank. Plug
In the event of not using purifier for a long time
back the drain plug and switch on the power
(while going for a holiday, tour etc.), make sure
supply
that you disconnect the power supply, turn off
the raw water supply and drain the storage
Replace sediment filter & activated carbon filter
tank
once in a year. It is recommended to change
FRT along with the filters
To ensure that the purifier operates at its BEST, a routine maintenance must be performed. The
frequency of the maintenance will greatly depend upon the raw water quality and consumption of
purified water.
The replacement time of consumables such as filters and membrane is dependent
on the quality of raw water and water consumed.
* Tested & Certified by TUV-SUD South Asia (P) Ltd.
** Tested or certified flushing time - 24hrs.
Note: Filters and membrane are consumables. Their replacement time is dependent on the quality of raw
water and water consumption. They are not covered under the warranty. However, if a filter chokes within six
months and a membrane within a year, it will be cleaned/repaired/replaced free of cost. Changing the filters
and system inspection is available on call. The treatment capacity of RO membrane will reduce with time due
to clogging of pores of membranes.
“This reverse osmosis system contains a replaceable component critical to the efficiency of the system.
Replacement of the reverse osmosis component should be with one of identical specifications as defined by
the manufacturer, to ensure the same efficiency and contaminant reduction performance.”
The reverse osmosis system contains a replaceable treatment component critical for the effective reduction
of total dissolved solids and that product water shall be tested periodically to verify that the system is
performing properly.
Replacement of spare parts are as under:-
-20010 SP Inline Sediment Filter 8”
-20009 SP Inline Carbon Filter 8”
-20001 SP RO Membrane Welded 10” Housing
-20004 SP UF Membrane Welded 8”
-20018 SP FRT 550
n
n
Turning the screw of the valve clockwise
results in a decreased mineral content.
Turning the screw of the valve anti-clockwise
results in an increased mineral content.
The unique TDS Control System enables customers to retain the contents of natural minerals (TDS) in
purified water, as per their requirement.
