SET-UP 5
en-14
5Set-up
5.1
GENERAL ________________________________________________________________
A qualified technician must always do the assembly, adjustment and mower tests. The technician must know the
correct operation of this equipment.
Completely read each instruction and make sure you understand the instructions before continue with the assembly.
Look for possible hazards and obey all safety precautions.
The RIGHT and LEFT, FRONT and BEHIND the machine are given from the operator’s position.
Order the accessories not included with this product separately. See the accessory instructions accessory for
installation and parts.
5.2
INITIAL INSPECTION _______________________________________________________
Do a visual inspection of the mower. Look for indications of wear or loose hardware. Look for any components that are
not included on the mower or damaged components. Inspect paint and decals for damage or scratches. Decals provide
important safety and operating information. Replace all missing or hard to read decals.
5.3
ENGINE OIL
______________________________________________________________________
1.
Place the mower on a flat and level surface.
2.
Remove the oil cap/dipstick. Check to make sure there is no oil in the
crankcase.
3.
Slowly add the correct amount of engine oil. Do not overfill the engine.
• 20 inch (50.8 cm) HoverKing - 18.6 oz. (0.55 l)
• 16 inch (40.6 cm) HoverKing - 8.4 oz. (0.25 l)
4.
Wait three to five minutes and check the engine oil level.
• Clean the dipstick with a lint-free cloth.
• Insert the dipstick until the cap touches the engine base. Do not
screw the cap into the engine.
• Remove the dipstick. Engine oil must be between the upper and
lower level marks.
• If the engine oil level is above the upper level mark, remove the
excess engine oil.
• If the engine oil level is below the lower limit mark, add more engine
oil. Check the oil level again. Do not overfill the engine.
5.
Insert the dipstick and hand tighten the oil cap.
6.
Change the engine oil after the first 5 hours of operation.
CAUTION
Do not operate the mower unless you know this type of equipment and know how to operate all controls correctly.
NOTICE
Your mower was shipped from the factory without oil in the engine crankcase. Make certain the engine oil is
added before you start the engine. The damage caused by low or no oil in the engine is not covered under
the warranty.
!
Lower Limit Mark
Upper Limit Mark
Oil cap and
dipstick
Oil cap and
dipstick
20 inch
HoverKing
Engine
16 inch
HoverKing
Engine
