Ingersoll-Rand P185WIR, Operating, Maintenance & Parts Manual

Page: 61 / 119

S
If the engine cranking speed is so slow that the engine does not start
up, recharge the battery.
S
If the engine still will not start after charging, replace the battery.
S
Remove the battery from the battery mounting of the machine unit
after daily use if letting the machine unit leave in the place that the
ambient temperature could drop at --15
_
C or less. And store the battery
in a warm place until the next use the unit to start the engine easily at
low ambient temperature.
OPTION
Follow the instructions an precautions in the manual from the battery
maker.
A. Battery fluid
B. Lower limit
C. Upper limit
Inspection every 250 hours operation
(1) Replacing the engine oil and engine oil filter (2nd time and
after)
Replace the engine oil every 250 hours operation from 2nd time and on.
Replace the engine oil filter at the same time. Refer to 50 hour
inspection, section (1).
(2) Checking and cleaning radiator fins.
Beware of dirt from air blowing
Wear--protective equipment such as goggles to
protect your eyes when blowing compressed air.
Dust or flying debris can hurt eyes.
Dirt and dust adhering on the radiator fins reduce the cooling
performance, causing overheating. Make it a rule to check the radiator
fins daily and clean as needed.
S
Blow off dirt and dust from fins and periphery with compressed air
[0.19MPa (2kgf/cm
2
) or less] not to damage the fins with compressed
air.
S
If contaminated heavily, apply detergent, thoroughly clean and rinse
with tap water shower.
A. Dust, dirt.
B. Radiator fins
C. Air blow
IMPORTANT:
Never use high pressure water or air from close by fins or never attempt
to clean using a wire brush. Radiator fins can be damaged.