6
7
Warning Tag and Labels
The warning tag illustrated below in Figure is supplied with each hoist and trolley shipped from
the factory. If the tag is not attached to the pendant cord for your hoist/trolley, order a tag from
your dealer and fixit it. Read and obey all warnings attached to this Hoist/Trolley. Tag is not shown
in actual size.
WARNING
IMPROPER use of powered Hoist could result in death
Or serious injury.
To avoid these hazards:
ALWAYS read owner’s manual and safety
instructions.
Do NOT lift more than rated load.
Do NOT lift or transport loads over or near people.
Do NOT use a hoist for lifting supporting or
transporting people.
Do NOT operate unless load is centered under
hoist.
Do NOT support a load on the tip of the hook
Do NOT use a hoist if the hook latch is missing or
broken.
Do NOT remove or obscure the warning lables.
Do NOT run the load chain or wire rope over a
sharp edge.
Do NOT use the load chain or wire rope as a sling.
Do NOT operate beyond the travel limits of the
hook or load block.
Do NOT use a twisted, kinked, damaged, or
stretched load chain or wire rope.
Do NOT operate a wire rope hoist with a wire rope
that is not properly seated in its groove.
Hercules Hoists Limited ©2020
Note :- Due to continuous development and improvement specification listed above may be changed without notice
Indef CHAIN ELECTRIC HOIST
Hercules Hoists Limited ©2020
Note :- Due to continuous development and improvement specification listed above may be changed without notice
CONDITIONS WHERE WARRANTY WILL BE VOID / NOT APPLICABLE
HHL does not provide reimbursement for maintenance and visit charges for items such as: brake
adjustments, lubrication oil changes, or any other item or activity deemed solely by HHL to be
maintenance related.
HHL will not be liable for damage or malfunction and consequently warranty resulting from:
a. Lack of maintenance.
b. Use of improper or insufficient lubricants
c. Supply voltage high/low or insufficient.
d. Environmental conditions (including but not limited to extreme temperatures, humidity and
corrosive environments).
e. Outdoor applications where HHL is not intimated and recommendations for protection from
the elements are not followed.
f. Misuse or abuse (including but not limited to overloading, shock loading, or side / angular
lifting / pulling).
g. Use of parts other than genuine HHL replacement parts.
h. Improper repairs or maintenance.
i. Modifications not approved by HHL.
j. Improper handling of product after it leaves HHL factory.
k. Fire, accidents, or acts of God or nature, including but not limited to floods, hurricanes and
lightning.
l. Any piece of equipment not supplied by Hercules Hoists Limited, is installed on products.
m. Malfunction or damage caused by items added to Hercules Hoists Limited products,
including but not limited to controls and control components.
n. Relocation of hoist / equipment without proper installation and commissioning by HHL /
ABP.
o. Misalignment in existing / installed Crane rail and hoist monorail, improper existing power
feed track.
Hercules Hoists Limited ©2020
Note :- Due to continuous development and improvement specification listed above may be changed without notice
Hercules Hoists Limited ©2020
Note :- Due to continuous development and improvement specification listed above may be changed without notice
Indef CHAIN ELECTRIC HOIST
