Hubbell Lighting, Inc. Doc. No. 93062486
A subsidiary of Hubbell Incorporated Revision A
701 Millennium Drive • Greenville, SC 29607 Phone (864) 678-1000
Industrial Lighting
®
PAGE 3
FIGURE 7
FIGURA 7
FIGURE 9
FIGURA 9
5/16 MNTG SCREW (J)
INTO RAIL SLIDE NUT (K)
TORQUE: 120 IN-LB
HHH (MODULAR HIGHBAY)
INSTALLATION INSTRUCTIONS
SEE WARNINGS ON CARTON
WARNINGS:
Observe all precautions usually followed when dealing with high
voltage equipment when installing or servicing this light fixture.
Disconnect power before installing or servicing.
The product must be installed in accordance with the applicable
installation code by a person familiar with the construction and
operation of the product and the hazards involved.
Protect all wiring connections with approved insulators rated
600V. 150
O
C.
Line voltage must be 120V – 277V to match Fixture voltage
requirement.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE
Upon receipt of this Fixture, thoroughly inspect it for any damage.
If any is found, the carrier should be notified and held
accountable.
INSTALLING AIRCRAFT CABLE MOUNTING SYSTEM
(See Figure 7 and 8):
WARNING! NOTICE AIRCRAFT CABLE KIT TYPE SHIPPED
WITH YOUR ORDER:
2mm KIT FOR LOWBAY SERIES ONLY!
3mm KIT FOR HIGHBAY SERIES ONLY!
1.
Install AC Mounting Bracket (R) onto each corner of the rail, inset
approximately 1-inch from the rail end. Using 5/16” Screw (J)
provided in the hardware kit, insert the screw through the bottom
hole of each backet and install into the Slide Nut (K) pre-installed
within the rail. Ensure the bracket when pre-tightened is vertically
oriented as shown in Figure 8.
2.
Tighten AC Mounting Bracket Screw (J) to torque noted in Fig. 8,
while supporting the bracket orientation to prevent rotating during
the tightening sequence.
3.
Insert each Snap Hook Eyelet of the Y-Cable Ass’y onto the AC
Mounting Bracket top holes on each end of the fixture so that the
cable spans across the lightbar as shown in Figure 7.
4.
The Top Cable of the Aircraft System is lopped around a facility
structural member suitable to support the fixture load. The bare
cable end being inserted into the Top Cable Loop and then
proceeding into the Gripper. The Top Cable length should be
adjusted to desired length according to mounting height selected).
5.
Repeat for other side of the fixture cable mounting.
6.
Final adjustment of the Gripper Barrel position across the width of
the fixture will balance the fixture, while Top Cable Length
adjustment will balance the fixture lengthwise. See Figure 7
illustration.
7.
Install lens option onto each Lightbar, see Figure 9. If wireguard
was ordered, lenses will ship installed on fixture.
8.
Complete electrical connection by installing AC Input Cord into
AC Panel as shown in Figure 10.
AIRCRAFT CABLE KIT
( 2mm KIT FOR LB, 3mm KIT FOR HB)
FIGURE 8
FIGURA 8
ACRYLIC LENS: SNAP INTO
LIGHTBAR GROOVE
AIRCRAFT
MNTG OPTION
BRACKET (R)
AIRCRAFT CABLE KIT
( 2mm KIT FOR LB, 3mm KIT FOR HB)
FIGURE 10
FIGURA 10
Hubbell Lighting, Inc.
A subsidiary of Hubbell Incorporated
701 Millennium Drive • Greenville, SC 29607
Industrial Lighting
®
PAGE 4
HHH WIRING DIAGRAMS
GROUND
GREEN
LINE
(HOT) BLACK
BLACK
WHITE
RED
R
E
D
W
H
T
B
L
K
FUSING
WIHUBB OPTION
(ETO ONLY)
FUSING
SINGLE FUSE
OPTION
DOUBLE FUSE
OPTION
OCCUPANCY SENSOR
(OCS) OPTION
R
E
D
W
H
T
B
L
K
SURGE
SUPPRESSOR
CONTROL SENSOR (WST)
(ETO ONLY)
WIRELESS CONTROL DEVICE
(WIS) OPTION
WHITE
BLACK
DC INPUT
PANEL CONNECTOR
LIGHTBAR
+
-
+
-
DC OUTPUT
PANEL CONNECTOR
FROM DRIVER MDL
INTERCONNECT CORDSET ASSY'S
90° HEAD BOTH ENDS - MALE PINS ON
DRIVER OUTPUT, FEMALE END TOWARDS LIGHTBAR)
DRVR
RED
BLUE
RED
BLUE
BRWN
BLUE
BRWN
BLUE
R
E
D
W
H
T
B
L
K
GREEN
BLACK
WHITE
Doc. No. 93062486
Revision A
Phone (864) 678-1000
HHH MODULAR LOWBAY LOW OUTPUT ASSEMBLY
WIRING DIAGRAM "LOWBAY TWIN"
HHH-xK-LB-LO
WIRING DIAGRAMS
INSTALLATION INSTRUCTIONS
HHH (MODULAR HIGHBAY)
INSTALLATION INSTRUCTIONS
Hubbell Lighting, Inc. Doc. No. 93062486
A subsidiary of Hubbell Incorporated Revision C
701 Millennium Drive • Greenville, SC 29607 Phone (864) 678-1000
Industrial Lighting
®
PAGE 1
SEE TABLE
BELOW
FIGURE 11
FIGURA 11
HHH (MODULAR HIGHBAY) - LOOSE DIMMING LEADS WIRING TO HOUSE SUPPLY
Item
Service/Repl Part Nr
(incl. packaging)
Light Engines
15‐inch LED boards 5K
93075032
26‐inch LED board 5K
93075033
15‐inch LED boards 4K
93075034
26‐inch LED board 4K
93075035
Drivers
95W Driver 120‐277V
93075036
50W Driver
93075037
95W Driver 347‐480V
93075038
Lenses
15‐Inch diffuse
93075043
26‐inch diffuse
93075044
15‐inch medium
93075045
26‐inch medium
93075046
15‐inch narrow
93075047
26‐inch narrow
93075048
15‐inch wide
93075049
26‐inch wide
93075050
Wire Guard
15‐inch flat
93075051
26‐inch flat
93075052
15‐inch Round
93075054
26‐inch Round
93075055
15‐inch flat
93077270
26‐inch flat
93077271
15‐inch Round
93077272
26‐inch Round
93077273
HHH REPLACEMENT PARTS
Dimming Connection
Color Code Matrix
House Supply Lead Colors
Positive (+) Negative (‐)
Violet (po)
Violet
‐
Gray (negative ‐)
‐
Gray
Violet (po)
Brown
‐
Gray (negative ‐)
‐
Blue
Fixture Dimming Cable
Lead Colors
Alternate
Default
DIMMING CONNECTIONS BY COLOR CODE
HHH (MODULAR HIGHBAY)
INSTALLATION INSTRUCTIONS
Hubbell Lighting, Inc. Doc. No. 93062486
A subsidiary of Hubbell Incorporated Revision C
701 Millennium Drive • Greenville, SC 29607 Phone (864) 678-1000
Industrial Lighting
®
PAGE 1
SEE TABLE
BELOW
FIGURE 11
FIGURA 11
HHH (MODULAR HIGHBAY) - LOOSE DIMMING LEADS WIRING TO HOUSE SUPPLY
Item
Service/Repl Part Nr
(incl. packaging)
Light Engines
15‐inch LED boards 5K
93075032
26‐inch LED board 5K
93075033
15‐inch LED boards 4K
93075034
26‐inch LED board 4K
93075035
Drivers
95W Driver 120‐277V
93075036
50W Driver
93075037
95W Driver 347‐480V
93075038
Lenses
15‐Inch diffuse
93075043
26‐inch diffuse
93075044
15‐inch medium
93075045
26‐inch medium
93075046
15‐inch narrow
93075047
26‐inch narrow
93075048
15‐inch wide
93075049
26‐inch wide
93075050
Wire Guard
15‐inch flat
93075051
26‐inch flat
93075052
15‐inch Round
93075054
26‐inch Round
93075055
15‐inch flat
93077270
26‐inch flat
93077271
15‐inch Round
93077272
26‐inch Round
93077273
HHH REPLACEMENT PARTS
Dimming Connection
Color Code Matrix
House Supply Lead Colors
Positive (+) Negative (‐)
Violet (po)
Violet
‐
Gray (negative ‐)
‐
Gray
Violet (po)
Brown
‐
Gray (negative ‐)
‐
Blue
Fixture Dimming Cable
Lead Colors
Alternate
Default
DIMMING CONNECTIONS BY COLOR CODE
HHH (MODULAR HIGHBAY)
INSTALLATION INSTRUCTIONS
Hubbell Lighting, Inc. Doc. No. 93062486
A subsidiary of Hubbell Incorporated Revision C
701 Millennium Drive • Greenville, SC 29607 Phone (864) 678-1000
Industrial Lighting
®
PAGE 1
SEE TABLE
BELOW
FIGURE 11
FIGURA 11
HHH (MODULAR HIGHBAY) - LOOSE DIMMING LEADS WIRING TO HOUSE SUPPLY
Item
Service/Repl Part Nr
(incl. packaging)
Light Engines
15‐inch LED boards 5K
93075032
26‐inch LED board 5K
93075033
15‐inch LED boards 4K
93075034
26‐inch LED board 4K
93075035
Drivers
95W Driver 120‐277V
93075036
50W Driver
93075037
95W Driver 347‐480V
93075038
Lenses
15‐Inch diffuse
93075043
26‐inch diffuse
93075044
15‐inch medium
93075045
26‐inch medium
93075046
15‐inch narrow
93075047
26‐inch narrow
93075048
15‐inch wide
93075049
26‐inch wide
93075050
Wire Guard
15‐inch flat
93075051
26‐inch flat
93075052
15‐inch Round
93075054
26‐inch Round
93075055
15‐inch flat
93077270
26‐inch flat
93077271
15‐inch Round
93077272
26‐inch Round
93077273
HHH REPLACEMENT PARTS
Dimming Connection
Color Code Matrix
House Supply Lead Colors
Positive (+) Negative (‐)
Violet (po)
Violet
‐
Gray (negative ‐)
‐
Gray
Violet (po)
Brown
‐
Gray (negative ‐)
‐
Blue
Fixture Dimming Cable
Lead Colors
Alternate
Default
DIMMING CONNECTIONS BY COLOR CODE
HHH (MODULAR HIGHBAY)
INSTALLATION INSTRUCTIONS
Hubbell Lighting, Inc. Doc. No. 93062486
A subsidiary of Hubbell Incorporated Revision C
701 Millennium Drive • Greenville, SC 29607 Phone (864) 678-1000
Industrial Lighting
®
PAGE 1
SEE TABLE
BELOW
FIGURE 11
FIGURA 11
HHH (MODULAR HIGHBAY) - LOOSE DIMMING LEADS WIRING TO HOUSE SUPPLY
Item
Service/Repl Part Nr
(incl. packaging)
Light Engines
15‐inch LED boards 5K
93075032
26‐inch LED board 5K
93075033
15‐inch LED boards 4K
93075034
26‐inch LED board 4K
93075035
Drivers
95W Driver 120‐277V
93075036
50W Driver
93075037
95W Driver 347‐480V
93075038
Lenses
15‐Inch diffuse
93075043
26‐inch diffuse
93075044
15‐inch medium
93075045
26‐inch medium
93075046
15‐inch narrow
93075047
26‐inch narrow
93075048
15‐inch wide
93075049
26‐inch wide
93075050
Wire Guard
15‐inch flat
93075051
26‐inch flat
93075052
15‐inch Round
93075054
26‐inch Round
93075055
15‐inch flat
93077270
26‐inch flat
93077271
15‐inch Round
93077272
26‐inch Round
93077273
HHH REPLACEMENT PARTS
Dimming Connection
Color Code Matrix
House Supply Lead Colors
Positive (+) Negative (‐)
Violet (po)
Violet
‐
Gray (negative ‐)
‐
Gray
Violet (po)
Brown
‐
Gray (negative ‐)
‐
Blue
Fixture Dimming Cable
Lead Colors
Alternate
Default
DIMMING CONNECTIONS BY COLOR CODE
HHH (MODULAR HIGHBAY)
INSTALLATION INSTRUCTIONS
Hubbell Lighting, Inc. Doc. No. 93062486
A subsidiary of Hubbell Incorporated Revision C
701 Millennium Drive • Greenville, SC 29607 Phone (864) 678-1000
Industrial Lighting
®
PAGE 1
SEE TABLE
BELOW
FIGURE 11
FIGURA 11
HHH (MODULAR HIGHBAY) - LOOSE DIMMING LEADS WIRING TO HOUSE SUPPLY
Item
Service/Repl Part Nr
(incl. packaging)
Light Engines
15‐inch LED boards 5K
93075032
26‐inch LED board 5K
93075033
15‐inch LED boards 4K
93075034
26‐inch LED board 4K
93075035
Drivers
95W Driver 120‐277V
93075036
50W Driver
93075037
95W Driver 347‐480V
93075038
Lenses
15‐Inch diffuse
93075043
26‐inch diffuse
93075044
15‐inch medium
93075045
26‐inch medium
93075046
15‐inch narrow
93075047
26‐inch narrow
93075048
15‐inch wide
93075049
26‐inch wide
93075050
Wire Guard
15‐inch flat
93075051
26‐inch flat
93075052
15‐inch Round
93075054
26‐inch Round
93075055
15‐inch flat
93077270
26‐inch flat
93077271
15‐inch Round
93077272
26‐inch Round
93077273
HHH REPLACEMENT PARTS
Dimming Connection
Color Code Matrix
House Supply Lead Colors
Positive (+) Negative (‐)
Violet (po)
Violet
‐
Gray (negative ‐)
‐
Gray
Violet (po)
Brown
‐
Gray (negative ‐)
‐
Blue
Fixture Dimming Cable
Lead Colors
Alternate
Default
DIMMING CONNECTIONS BY COLOR CODE
