HOME REFINEMENTS JULIEN HR-ELGG32-P, Installation And Maintenance Manual

Page: 92 / 96

92
TROUBLESHOOTING
The grill will not light
• Is the propane tank valve turned “OFF”?
Turn “ON” the valve.
• Is the grill properly connected to the gas supply?
Check installation instructions.
• Is there any gas in the propane tank?
Check the gas level before using the grill.
• Is the igniter working?
Check if the igniter battery is properly installed,
also check if the battery needs to be replaced.
Check if the grill lit when using a match.
Check if there’s any debris blocking the electrode.
• If the igniter is not sparking at the tip of the
electrode, you might need to replace the igniter.
The burner flame will not stay lit
• Is the gas supply valve turned on at the correct
position?
Check the position of the gas valve, adjust the gas
valve according to the flame performance.
• Is the gas level in the tank low?
Check the gas level.
• Is the burner properly installed and in good
condition?
Check that the burner is installed properly. Check
for defects in the burner.
I have excessive flare-ups
• Is there excessive fat in the food being grilled?
Keep the flame on low or turn one burner “OFF”.
Keep the hood up when grilling to avoid excessive
flare-ups. Move the food to the warming rack until
flames subside. To avoid damage to the grill, do
not spray water on gas flames.
I want to replace the light Bulb
• Take out the grease tray and find the grill light
bulb connector.
• Take out the 5 screws on the lamp cover to get
access to the bulb.
The flame is noisy, low or erratic
• Is the gas supply fully turned on?
Check if the propane tank valve is fully open.
• Is the gas level in the tank low?
Check the gas level.
• Does only one burner appear low?
Check and clean the burner if it’s clogged or dirty.
See the “General Cleaning” section.
• Is the gas supply hose bent or kinked?
Straighten the gas supply hose.
• Is the flame noisy or lifting away from the burner?
Burner may be getting too much air. Check the air
shutter adjustment
• Is the burner flame mostly yellow or orange?
The grill may be in an area that is too windy or
it is not receiving enough air. Check the burner
air inlets for obstructions. Check the air shutter
adjustment, see the “Check and Adjust Burners”
section.
The heat is low with my LP gas cylinder
For outdoor grills using a propane tank, slowly open
the tank valve.
NOTE: If the flow limiting device activates, your grill
may not light. If your grill does light, the flames will be
low and will not heat properly.
1. Turn the tank valve and all control knobs
“OFF”and wait 30 seconds.
2. After shutting off the tank, slowly open the tank
valve and wait 5 seconds before lighting.
3. Light one burner at a time. See the “Lighting the
Main Grill” section.