HomComfort HCPHTTM, Manual

Page: 10 / 28

10
BETWEEN USES
• Turn the control knob to the “OFF” position.
• Open the door and disconnect the cylinder.
• Store the heater upright in an area sheltered from direct contact with inclement weather (such as rain, sleet,
hail, snow, dust and debris).
• To protect the exterior surfaces and help prevent debris in the air passages, cover the heater.
DURING PERIODS OF EXTENDED INACTIVITY OR WHEN TRANSPORTING
• Turn the control knob to the “OFF” position.
• Disconnect the LP cylinder and move to a secure well-ventilated location outdoors. Do NOT store in a
location that will exceed 125 degrees F.
• The propane cylinder must be stored outdoors in a well-ventilated area. It must be out of reach of children,
and not in a building, garage, or any other enclosed area.
• Store heater upright in an area sheltered from direct contact with inclement weather (such as rain, sleet,
hail, snow, and debris). If desired, cover the heater to protect surfaces and to help prevent debris in air
passages.
NOTE: Wait until the heater is cool before covering
Storage
Troubleshooting
PROBLEM PROBABLE CAUSE SOLUTION
Pilot will not light
Gas valve may be off Turn the gas valve on
Fuel tank empty Refill the LP gas tank
Orifice blocked Clean or replace orifice
Air in the supply system Purge air from lines
Loose connection Check all fittings
Pilot will not stay on
Debris around pilot Clean dirty area
Loose connection Tighten connection
Thermocouple is bad Replace thermocouple
Gas leak in line Check connection
Lack of fuel pressure Fuel tank is near empty
Burner will not light
Pressure is low Fuel tank is near empty
Orifice blocked Remove, clean, and replace
Control valve is not on Turn valve to the “ON” position
Thermocouple is bad Replace the thermocouple
Pilot light assembly bent or not in correct location Place pilot in proper position and retry