11
Installation
ImPOrTANT:
The mounting frame/surround assembly
and flue piping is the most critical part of the installation
and must be done correctly and installed
securely.
1
. Choose the chimney configuration that is best suited
for the installation. See venting section. Page 21
• Note: If 100% outside air is desired or required, the
outside air option will need to be installed on the stoves
body. (See instructions included with outside air kit (part
#1-00-674080.) See Page 22.
2.
Make sure the unit will fit into the fireplace opening.
When installing in smaller fireplaces, test fit the mounting
frame into the firebox. Note: The unit overhangs to the
rear. See Fig. 17
3.
Install the 3 piece cast surround set to the sides
and top of the mounting frame with the bolts and nuts
supplied. The left and right side should be done before
the center section is installed. Make sure the bolts are
loose. Do not remove the side panel hinges. The left and
right side wings should be standing up aligned with the
side of the mounting frame and slid inward towards the
center. Note:The wings mount on the rear side below
the notch and on the front side above the notch. See
Fig. 16 & 18. Slide the cast ash lip onto the frame and
check to make sure it can go against the roped frame
rails and fits into the pockets on the left and right cast
sides. See Fig. 19.
Install the center section.
4.
If the wing extension is required, it should be installed
next.
beginning Installation
NOTE: The stove body extends through the mounting
frame in the rear approximately 2".
Approximately 2" overhang
Fig. 17
Cast in front of
the frame. Use
(1)1/4-20 x 3/8
flange bolt from
the rear.
Cast behind the
mounting frame
flange. Use (2)
1/4-20x5/8 flange
bolts and nuts
with bolts from
the front.
Fig. 18
Slide the ash lip
casting into the
frame, making
certain the ash
lip is sitting on
the slide rails on
either side. With
the ash lip in
place, adjust the
surround sides so
there is an even
gap where the
ash lip extends
into the surround
side and tighten.
Fig. 19
3" Outside Air
starter collar
Fig. 16
Notch
Ash lip slide rails
Summary of Contents for Harman Accentra Insert
Page 36: ......
Page 37: ......
Page 44: ...44 Service Maintenance Log Date Of Service Performed By Description Of Service...
Page 47: ......
