414-03B-56
414-03B-56
High Voltage/Traction Battery — Nickel Metal Hydride
DIAGNOSIS AND TESTING (Continued)
PINPOINT TEST P: IOM TO BCM DIAGNOSTIC INPUT STUCK HIGH FAULT
TEST STEP
ACTION TO TAKE
No =
GO to P4.
WARNING: The traction battery contains high-voltage
components and wiring. High-voltage insulated safety gloves and face
shield must be worn when carrying out the following steps. Failure to
follow this warning may result in severe personal injury or death.
•
Connect Traction Battery Low-Voltage Service Cord to traction battery
support tray in-line C1939F and in-line C1939M.
•
Connect Traction Battery High-Voltage Service Cord to traction battery
support tray in-line C1935F and in-line C1935M.
•
With key OFF, disconnect IOM C1810 and measure the voltage between
pin 29 (PK/BK wire) and pin 16 (BK wire) on IOM C1810.
•
Is the voltage greater than 10 volts?
P4 CHECK GROUND TO IOM
•
With key OFF, measure the resistance between pin 16 (BK/W wire) on
Yes =
REPAIR the PK/BK wire
IOM C1810 and ground (BCM case).
between IOM C1810 and
in-line C1939F.
•
Is the resistance less than 5 ohms?
No =
REPAIR the BK/W wire.
P5 CHECK WIRES TO IOM BATTERY TEMPERATURE SENSORS
FOR OPEN(S)
•
Measure the resistance of the wires indicated below for the IOM battery
Yes =
GO to P6.
temperature sensors:
No =
REPAIR the wire(s) in
question.
IOM Battery Temperature Sensor #1:
•
With key OFF, disconnect IOM battery temperature sensor #1 C1803 and
measure the resistance of the LB wire between pin 35 on IOM C1810
and temperature sensor #1 C1803.
•
With key OFF, measure the resistance of the O wire between pin 22 on
IOM C1810 and temperature sensor #1 C1803.
IOM Battery Temperature Sensor #2:
•
With key OFF, disconnect IOM battery temperature sensor #2 C1804 and
measure the resistance of the LG wire between pin 36 on IOM C1810
and temperature sensor #2 C1804.
•
With key OFF, measure the resistance of the W wire between pin 23 on
IOM C1810 and temperature sensor #2 C1804.
IOM Battery Temperature Sensor #3:
•
With key OFF, disconnect IOM battery temperature sensor #3 C1805 and
measure the resistance of the P wire between pin 37 on IOM C1810 and
temperature sensor #3 C1805.
•
With key OFF, measure the resistance of the BR wire between pin 24 on
IOM C1810 and temperature sensor #3 C1804.
•
Are the resistances less than 5 ohms?
P6 CHECK SIGNAL WIRES TO IOM BATTERY TEMPERATURE
SENSORS FOR SHORT(S) TO GROUND
•
With key OFF, measure the resistance between the pins on IOM C1810
Yes =
indicated below for the IOM battery temperature sensor signal wires:
No =
REPAIR the wire(s) in
question.
IOM Battery Temperature Sensor #1 (LB wire)
— pins 35 and 16
IOM Battery Temperature Sensor #2 (LG wire)
— pins 36 and 16
IOM Battery Temperature Sensor #3 (P wire)
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
