44
setting will be retained until a new adjustment is made. Brake controllers usually have a manual feature,
which allows you to apply the trailer brakes independently of the tow vehicle brakes. Connect the
controller to the brakes with 12-gauge stranded wire.
Chapter 6: Propane Gas System
Read all manufacturer appliance literature, including the information on the propane bottles and regulator,
provided within the unit packet and follow any instructions given.
General Information
Propane gas (also called LP, LPG or Liquefied Petroleum) when properly handled, is a clean burning
dependable fuel for operating all propane gas appliances. The propane gas system involves the tank(s)
(also called bottles or cylinders), regulators, valves, supply lines and appliances. Propane tanks contain
liquid under high pressure, which vaporizes into a gas and passes through the regulator to automatically
reduce the pressure. Low-pressure gas is then distributed through the supply lines to provide the fuel for
propane appliances.
Consumption of propane gas depends upon the frequency and duration of use of the propane appliances.
The refrigerator, range/oven, water heater and furnace all operate on propane. The furnace and oven
have the highest consumption rates. During cold weather it is advisable to check the bottles often and
always keep one full. Safety must be observed at all times when using the propane gas system. Propane
gas is colorless and odorless in its natural state. A strong odorant, similar to rotten egg smell, has been
added for consumer safety purposes to help detect leaks and provide warning.
Propane burns readily and yields a great deal of energy. Under proper conditions and careful handling, it
is safe, economical, and ideally suited for use where conventional fuels are not easily utilized.
Propane Regulator
The regulator is the heart of the propane system. Propane gas is under high pressure in the bottle and
the regulator reduces this pressure to less than one pound per square inch, to allow safe use with the
appliances in recreational vehicles.
The lower pressure is distributed to the appliances. The arrow on the automatic gas regulator will always
point to the gas bottle in service. When the red flag appears in the inspection glass, this indicates that
bottle is empty.
Care and Maintenance
The regulator has a vent that allows it to breathe. If pressure builds too high within the regulator, it vents
until pressure reaches a normal range. Check the vent frequently to keep the vent clean and clear of any
debris, corrosion or obstruction. A clogged regulator can result in higher pressures, loss of fuel and/or
component failure. The vent can be cleaned by using a toothbrush and should be checked periodically by
a qualified propane service center.
Summary of Contents for Escape 2014
Page 3: ......
