®
Outdoor Natural Gas Patio Heater Model No. 233010
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
WARNING
FOR YOUR SAFETY
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. If odor continues, immediately call your gas supplier or your fire
department.
This heater is for outdoor use only, and shall not be used in a building,
garage, or any other enclosed area.
Always maintain at least 36” clearance (top), and 24” clearance (side)
from combustible materials.
This heater is for use with natural gas only. The conversion to or
attempted use of liquid propane (LP) gas in this Natural gas heater is
dangerous and will void your warranty.
Natural gas Characteristics:
a. Natural gas is flammable and hazardous if handled improperly.
Become aware of the characteristics before using any Natural gas
product.
b. Natural gas is explosive under pressure, heavier than air, and settles
and pools in low areas.
c. Natural gas in its natural state has no odor. For your safety, an
odorant is added that smells like rotten cabbage.
d. Contact with natural gas can cause freeze burns to skin.
Never attempt to attach this heater to the self-contained natural gas
system of a camper trailer, motor home, or house.
The use of alcohol, or prescription or non-prescription drugs may
impair the consumer’s ability to properly assemble or safely operate the
appliance.
Your heater has been checked at all factory connections for leaks.
Recheck all connections, as movement in shipping can loosen
connections.
Check for leaks even if your unit was assembled for you by someone
else.
Do not operate if gas leak is present. Gas leaks may cause a fire or
explosion.
You must follow all leak-checking procedures before operating. To
prevent fire or explosion hazard when testing for a leak:
a. Always perform leak test before lighting the heater and each time the
tank is connected for use.
b. No smoking. Do not use or permit sources of ignition in the area
while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do not use matches, lighters, or a flame to check for leaks.
e. Do not use heater until any and all leaks are corrected.
If you are unable to stop a leak, disconnect the natural gas supply.
Call a gas appliance serviceman or your local natural gas supplier.
The appliance and its individual shutoff valve must be disconnected
from the gas supply piping system during any pressure testing of that
system at a pressure in excess of 1/2 psig (3.5 kpa).
The appliance must be isolated from the gas supply piping system by
closing its individual manual shutoff valve during any pressure testing
of the gas supply piping system at test pressure equal to or less than
1/2 psig (3.5 kpa).
Always perform a leak test on gas connections whenever this grill
is serviced. Never use a flame to test for leaks. Do not smoke while
performing leak check.
Do not store or use LP gas, gasoline or other flammable liquids or
vapors within 25 feet (7.62 m) of this appliance.
Do not use in an explosive atmosphere. Keep heater area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
Keep all combustible items and surfaces away from the heater at all
times. DO NOT use this heater or any gas product under any overhead or
near any unprotected combustible constructions.
Combustion of natural gas creates carbon monoxide, which, when used
in enclosed areas, can kill you.
It is essential to keep the heater’s valve compartment, burners, and
circulating air passages clean. Inspect heater before each use.
Installation and repair should be done by a qualified service person.
Do not alter heater in any manner.
Do not use the heater unless it is COMPLETELY assembled and all parts
are securely fastened and tightened.
This heater should be thoroughly inspected before each use. Clean and
inspect the hose before each use of the appliance. If there is evidence
of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the
appliance being put into operation.
Use only the hose assembly provided. The replacement hose assembly
shall be that specified by the manufacturer.
Inspect heater before each use. If a damaged part is detected, do not
operate until an original equipment replacement part has been properly
installed.
Use only Blue Rhino Global Sourcing, LLC. factory authorized parts. The
use of any part that is not factory authorized can be dangerous. This
will also void your warranty. Contact 1.800.762.1142.
Dome and burner are extremely hot to the touch during operation. Never
touch the dome or burner while the heater is operating. Wait for unit to
cool down (approximately 45 minutes) after use.
During operation, do not touch burner assembly. The surface of heater’s
emitter can reach temperatures approaching 1600ºF.
Do not install or use in or on boats or recreational vehicles.
Do not use heater in winds that exceed 10 m.p.h..
Do not leave a lit heater unattended, especially keep children and pets
away from heater at all times.
Always use extreme caution when near heater. Alert both children and
adults to the hazards of high temperatures, especially to avoid burns or
clothing catching fire.
Do not attempt to move heater when in use. Allow the heater to cool
before moving or storing.
Do not attempt to disconnect the gas regulator from the natural gas line
or any gas fitting while the heater is in use.
Always place your heater on a hard, level surface.
Use extreme caution on wooden decks.
Move gas hoses as far away as possible from hot surfaces.
Keep all electrical cords away from a hot heater.
Do not use heater for indoor cooking or heating. TOXIC fumes can
accumulate and cause asphyxiation.
Keep sprinklers and other water sources away from burner and
controls.
Do not hang clothing or other flammable materials either on or near
heater.
Always allow heater to cool before attempting service.
Any guard or other protective device removed for servicing the heater
must be replaced prior to operating the heater.
Certain materials or items, when stored under heater, will be subjected
to radiant heat and could be seriously damaged.
After a period of storage and/or nonuse, check for leaks, burner
obstructions and inspect for any abrasion, wear, cuts to the hose.
If at any time you are unable to light burner and smell gas, wait 5
minutes to allow gas to dissipate before attempting to light heater.
Failure to not wait 5 minutes to allow the gas to clear if the heater does
not light, may result in an explosive flame-up.
Be careful when attempting to manually ignite this heater. Holding in
the control knob for more than 10 seconds before igniting the gas will
cause a ball of flame upon ignition.
Avoid inhaling fumes emitted from the heater’s first use. Smoke and
odor from the burning of oils used in manufacturing will appear. Both
smoke and odor will dissipate after approximately 30 minutes. The
heater should NOT produce thick black smoke.
If heater is not in use, the gas must be turned off at the natural gas
main valve.
Do not use this appliance without reading “Operating Instructions” in
this manual.
Please use protective gloves when assembling this product.
Do not force parts together as this can result in personal injury or
damage to the product.
This appliance is designed to operate at an inlet pressure of 7 inches
water column.
Fuel system must be installed by a qualified and licensed personnel.
Improper installations present hazards, which can lead to personal
injury or property damage. Please contact your local natural gas
supplier for these services.
Deaths, serious injury or damage to property may occur if the above is
not followed exactly.
DANGERS and WARNINGS: FOR YOUR SAFETY
DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
WARNING:
WARNING
FOR YOUR SAFETY
1. Do not store spare LP cylinder within 10 feet (3.05 m) of this appliance.
2. Do not store or use gasoline or other flammable vapors and liquids
within 25 feet (7.62 m) of this or any other appliance.
3. An LP cylinder not connected for use shall not be stored in the vicinity
of this or any other appliance.
