Edwards xds35i, Instruction Manual, Page: 15 / 40

© Edwards Limited 2007. All rights reserved. Page 9
Edwards and the Edwards logo are trademarks of Edwards Limited.
In
st
al
la
ti
on
A730-01-880 Issue E
3 Installation
3.1 Safety
You must ensure that the XDS35i pump is suitable for your application. If you have any doubt about the suitability of
the XDS35i pump for your application, refer to the Edwards guidelines on vacuum pump and vacuum system safety
(see associated publications at the end of the contents list at the front of this manual).
A suitably trained and supervised technician must perform the installation of the XDS35i pump. Obey the safety
instructions listed below when you install the XDS pump, especially when you connect the pump into an existing
system. Details of the specific safety precautions are given at the appropriate point in the instructions.
z
Mechanical lifting equipment should be attached to the lifting eye on the pump.
z
Loose slings should not be used to lift the XDS35i.
z
Wear the appropriate safety clothing when you come into contact with contaminated components. Dismantle
and clean contaminated components inside a fume cupboard.
z
Vent and purge your vacuum system before you start installation work.
z
Ensure that the installation technician is familiar with the safety procedures that relate to the products
handled by the pumping system.
z
Disconnect the other components in the pumping system from the electrical supply so that they cannot be
operated accidentally.
WARNING
Obey the safety instructions given below and take note of appropriate precautions. If you do not,
you can cause injury to people and damage to equipment.
WARNING
The Edwards XDS35i pump is not recommended for pumping explosive gases or hazardous
substances.
WARNING
Prevent any part of the human body coming into contact with the vacuum.
WARNING
Use suitable lifting equipment to move the XDS35i pump. The mass of the pump is approximately
48 kg.
WARNING
Take care when moving the pump into position. The pump's weight makes it difficult to slide and
movement should be attempted using two people.