ECA PROTEUS PREMIX PPR Series, Operating Manual

Page: 45 / 47

*All installations in England and Wales must be to Local Authority Building Control (LABC ) either directly or through a
Competent Persons Scheme. A Building Regulations Compliance will then be issued to the customer.
www.centralheating.co.uk © H eating and H otwater Industry Council ( HH IC )
Th i s Comm i ss i on i ng Check li st i s to be comp l eted i n f u ll by the competent person who comm i ss i oned the bo il er as a means o f demonstrat i ng
comp li ance w i th the appropr i ate Bu il d i ng Regu l at i ons and then handed to the customer to keep f or f uture re f erence.
Failure to install and commission according to the manufacturer’s instructions and complete this Benchmark Commissioning Checklist will invalidate the
warranty. This does not affect the customer’s statutory rights.
GAS BO I LER SYSTEM COMM I SS I ON I NG CHECKL I ST
Customer name: Telephone number:
Address:
Boiler make and model:
Boiler serial number:
Commissioned by (PRINT NAME ) : Gas Safe register number:
Company name: Telephone number:
Company address:
Commissioning date:
CONTROLS (tick the appropriate boxes )
Time and temperature control to heating
Room thermostat and programmer/timer Programmable room thermostat
Load/weather compensation Optimum start control
Time and temperature control to hot water Cylinder thermostat and programmer/timer Combination Boiler
H eating zone valves Fitted Not required
H ot water zone valves Fitted Not required
Thermostatic radiator valves Fitted Not required
Automatic bypass to system Fitted Not required
Boiler interlock Provided
ALL SYSTEMS
’s instructions Yes
What system cleaner was used?
What inhibitor was used? Quantity litres
Yes No
CENTRAL HEAT I NG MODE measure and record:
Gas rate m³/hr OR ft³/hr
Burner operating pressure (if applicable ) mbar OR Gas inlet pressure mbar
°C
Central heating return temperature °C
COMB I NAT I ON BO I LERS ONLY
Is the installation in a hard water area (above 200ppm ) ? Yes No
Yes No
DOMEST I C HOT WATER MODE Measure and Record:
Gas rate m³/hr OR ft³/hr
Burner operating pressure (at maximum rate ) mbar OR Gas inlet pressure at maximum rate mbar
Cold water inlet temperature °C
H ot water has been checked at all outlets Yes Temperature °C
I/min
CONDENS I NG BO I LERS ONLY
The condensate drain has been installed in accordance with the manufacturer’s instructions and/or BS5546/BS6798 Yes
ALL I NSTALLAT I ONS
Record the following:
At max. rate: CO ppm AND CO/CO² Ratio
At min. rate: (where possible ) CO ppm AND CO/CO² Ratio
The heating and hot water system complies with the appropriate Building Regulations Yes
The boiler and associated products have been installed and commissioned in accordance with the manufacturer’s instructions Yes
The operation of the boiler and system controls have been demonstrated to and understood by the customer Yes
The manufacturer’s literature, including Benchmark Checklist and Service Record, has been explained and left with the customer Yes
Commissioning Engineer’s Signature
Customer’s Signature
www.centralheating.co.uk
45