Summary of Important Safety Information for Operation
33
Don't overfill
. DO NOT overfill the gas tank. Allow at least 1/2" of empty space below the fill neck to allow for
fuel expansion.
Replace cap
. Replace gas cap securely before starting engine.
Spills
. Clean up fuel spills immediately. Move log splitter away from spilled fuel on the ground. Wipe fuel off
engine and wait 5 minutes for excess fuel to evaporate before starting engine. Gas soaked rags should be disposed
of properly.
On skin / clothes
. If gasoline is spilled on your skin or clothes, change clothes and wash skin immediately.
Gasoline storage
. Store gasoline in a cool, dry place in an UL approved, tightly sealed container.
Safety in Work Site Selection
Spark arrestor
. If your splitter will be used near any unimproved forest, brush, or grassy covered land, then engine
should be equipped with a spark arrestor. See the "Specifications" section of this manual to determine if your
splitter already has a spark arrestor. Make sure you comply with applicable local, state and federal codes.
Hot exhaust
. Hot exhaust fumes from engine can cause fire. Position muffler at least 7' from combustible objects
during operation.
Fire extinguisher
. Have a Class ABC fire extinguisher available as a precautionary measure when operating the
log splitter in dry areas
.
Level, dry surface
. To prevent accidental falls and equipment tip over, make sure the splitter is situated on a dry,
level surface with good footing. Stay clear of areas with mud, ice, tall grass, weeds, brush, or snow.
Block wheels
. Always block the wheels to prevent unintended movement of the log splitter.
Carbon monoxide
. The running engine gives off carbon monoxide, a poisonous gas that can kill you. You
CANNOT smell it, see it, or taste it. ONLY run log splitter OUTDOORS and away from air intakes. NEVER run
log splitter inside homes, garages, sheds, or other semi-enclosed spaces. These spaces can trap poisonous gases,
EVEN if you run a fan or open windows. If you start to feel sick, dizzy, or weak while using the log splitter, shut
off the engine and get to fresh air RIGHT AWAY. See a doctor. You may have carbon monoxide poisoning.
Safety – During Use
General Safety During Use
WARNING:
Before starting this log splitter, review the following rules for safe operation. Failure to follow these
rules may result in serious injury to the operator or bystanders.
Safety equipment / controls
. Always operate the log splitter with all safety equipment in place and in good
working order, and all controls properly adjusted for safe operation.
Operating speed.
Always operate the log splitter at the manufacturer's recommended speed. The maximum speed
of the engine, pump and wedge are preset within safe limits.
Know how to stop
. Be thoroughly familiar with all controls and with the proper use of the equipment. Know how
to stop the log splitter and relieve system pressures quickly if needed.
Daylight only
. Only use the log splitter in daylight so you can see what you are doing.
Smoking / sparks
. Never smoke while operating the log splitter, and never operate near sources of sparks or
flames.
Hot muffler
. If you are starting a warm engine, stay clear of muffler. It may still be hot enough to burn you.
Unattended
. Never leave the machine unattended while the engine is running.
Under the influence
. Never operate, or let anyone else operate, the log splitter while under the influence of
alcohol, drugs, or medication.
Adjusting / repairing
. Always make sure the engine is off before cleaning, repairing or adjusting the splitter,
except as recommended by the manufacturer. In addition, disconnect the spark plug and move all control handles
back and forth to relieve system pressure
before changing or adjusting hydraulic system components
such as hoses,
tubing, fittings or other components.
Carbon monoxide
. The running engine gives off carbon monoxide, a poisonous gas that can kill you. You
CANNOT smell it, see it, or taste it. If you start to feel sick, dizzy, or weak while using the log splitter, shut off the
engine and get to fresh air RIGHT AWAY. See a doctor. You may have carbon monoxide poisoning.
