6
7
Aquaclipse
Installation & Operations Manual
Aquaclipse
Installation & Operations Manual
Ozone will extend the useful life of both water vessels and
equipment since it is impossible to over-treat the water. In contrast,
a single overdose of chlorine can do serious damage.
NOTE: Although installing ozone on potable water tanks will
reduce or eliminate bacteria problems, it is not recommended
as a replacement to standard disinfection treatment.
SECTION 5 Maintenance & Service
5A . System Electromechanical Overview
5A-1 Internal Component
To access the internal components of the Aquaclipse, turn off the
Power Switch, disconnect power to the unit, then unlatch and fully
open the Front Cover. Remove the two Access Panel screws and
carefully swing the panel open.
To order replacement parts, refer to
Figure 2 for part numbers and
descriptions.
5B. Cleaning the Dispersion Stone
Periodically, the dispersion stone may clog up with mineral deposits
reducing the amount of ozone flow through the stone. The stone
will appear a darker color. Remove the dispersion stone. Soak
it in lemon juice or vinegar for a few hours to overnight until the
discoloration is gone and the dispersion stone is a uniform color.
Rinse the dispersion stone thoroughly with fresh water. Reinstall the
dispersion stone.
NOTE: Sometimes the stain will be permanent; if ozone
bubbles still flow from the dispersion stone the stain will not
affect operation.
# Description
Part Number
1
Ozone Module
9-1056-01
2
Manifold Mounting Bracket
8-1191-01
3
Compressor (120V models)
5-1936-01
Compressor (230V models)
5-1936-02
4
Ozone Cell Manifold
8-1159-02
5
Check Valve
7-1256-03
6
Tubing, 1/4"IDx3/8"OD
7-0964
7
Pressure Relief Valve
7-1419-01
8*
Fuse (120v)
5-4013
Fuse (240V)
5-0458
5C . Troubleshooting
The areas to check on the ZO-400 to determine the nature of a
problem are as follows:
1. The green power light on the front panel – should be on if the
system is in operation.
2. There should be air bubbles in the water.
*Not shown in Figure 2, refer to Section 3A
OZONE OUT
FITTING
OZONE
MODULE LIGHT
1
2
4
6
FAN
3
Figure 2: ZO-400 Internal View
5
7
FRONT COVER
ACCESS
PANEL
