Cushman 2012 Hauler 1200, Owner'S Manual

Page: 38 / 80

OPERATING PROCEDURES
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
4 - 4
4
BEFORE INITIAL USE
Read and follow the safety label on the instrument panel. Be sure you understand how to operate the vehicle and its
equipment as well as how to use it safely. Maintaining good performance depends to a large extent on the operator.
Hydrogen gas is generated as a natural part of the lead acid battery charging process. A 4% concentration of hydr
gen gas is explosive and could cause severe injury or death. Charging must take place in an area that is adequately
ventilated (minimum of 5 air exchanges per hour).
To reduce the chance of battery explosion that could result in severe injury or death, never smoke around or charge
batteries in an area that has open flame or electrical equipment that could cause an electrical arc.
Before a new vehicle is put into operation, the items shown in the INITIAL SERVICE CHART must be performed.
Vehicle battery must be fully charged before initial use.
Check for correct tire inflation.
Check for oil or fuel leaks that could have developed in shipment from the factory.
Determine and record braking distance required to stop vehicle for future brake performance tests.
Remove the protective clear plastic, that protect the seat bottom and back rest during shipping, before placing the
vehicle in service.
OPERATING THE VEHICLE
Improper use of the vehicle or the lack of proper maintenance may result in damage or decreased performance.
Read and understand the following warnings before attempting to operate the vehicle.
To reduce the possibility of severe injury or death resulting from loss of vehicle control, the fol-
lowing warnings must be observed:
When driving vehicle, consider the terrain, traffic conditions and the environmental factors which
effect the terrain and the ability to control the vehicle.
Use extra care and reduced speed when driving on poor surfaces, such as loose dirt, wet grass,
gravel, etc.
Stay in designated areas and avoid extremely rough terrain.
ITEM SERVICE OPERATION
Batteries Charge batteries
Seats Remove protective plastic covering
Brakes Check operation
Establish acceptable stopping distance
Tires Check air pressure (18 - 22 psi)
Portable Remove from vehicle and properly mount
Charger