Quest 2000 Service Manual
Publication Number: 720529901SER
- 6 -
© 2004, IMI Cornelius Inc.
3.
Press and hold the dispense button for 90 seconds then stop. Allow sanitizing solution to remain in
the lines for 5 minutes.
4.
After 5 minutes, dispense the remaining sanitizing solution.
Step 3 - Prepare Dispenser for Use
1.
Replace sanitizing solution container with a concentrate container and close the door.
2.
Press and hold the dispense button until juice appears from the nozzle. Next dispense and discard
at least two 8 oz. (236.6ML) cups of juice in order to prime the system and prepare it for operation.
S
EMI
-A
NNUAL
CAUTION: The following procedures require removal of the dispenser side panel(s).
Disconnect the power cord from the receptacle prior to proceeding.
Clean Water Inlet Strainer:
1.
Remove the right side panel from the dispenser.
2.
Turn off the water supply to the dispenser.
3.
Remove the access port from the “Y” shaped water inlet solenoid located on
the right side of the dispenser.
4.
Clean and reinstall the stainless steel water strainer.
Clean Chassis Interior:
1.
Clean the condenser cooling fins.
2.
Clean the air inlet grilles located on the rear and top panels of the dispenser.
3.
Clean the interior base.
4.
Wipe the fan blade clean.
5.
Reinstall the right side panel, turn on the water supply, and plug the dispenser into the power recep-
tacle.
Check and Top-Off Water Ice Bath:
1.
Remove the drip tray and lower splash panel.
2.
If the Ice bath level is below the “Full” indicator, top it off with water. Refer to the Filling the Ice Bath
procedure in the Installation section of this manual.
A
NNUALLY
Replace Pump Tubing:
A replacement pump tubing kit, part#45098, is
available. The kit consists of one pre-cut length of
pump tubing, two white plastic hose clamps, and
instructions.
Removing Pump Platform(s):
1.
Remove the concentrate containers from the dis-
penser and place them in a refrigerator.
2.
Remove the cabinet shelf that the concentrate
containers sit on.
Summary of Contents for 2 Flavor Post-Mix Cold Coffee Dispenser Quest 2000
Page 4: ......
