3
www.combisteel.com
BM series spiral mixers are a new type of kneader. Both the dough arm and bowl are running to be able to raise the mixing
speed and efficiency greatly. The machines are equipped with a protective cover, are easy to operate and safe. They are good
looking and easy to clean, suitable for mixing flour in hotels, restaurants and public canteens.
Technical specifications
Model
Voltage
Frequency
Power
IP
Rating
Bowl
volume
Dough max.
quantity
Dimension
(a×b×c) mm
Net
weight
7455.1400
~230
50Hz
1.1 kW
IPX1
20
6 kg
675×400×825
85 kg
7455.1405
~230
50Hz
1.5 kW
IPX1
30
12,5 kg
730x445x860
97 kg
Operation and Notes
1.
Set it on a dry horizontal plane (or support), place it firmly.
2.
Before use, ensure that the power supply corresponds to that required by the machine and that the external ground
wire is reliably connected.
3.
Ensure that flour mixing capacity is lower than the max. flour capacity.
4.
Before starting, ensure that the protective cover has been put down.
5.
Do not put hands and hard-things into the bowl while it runs.
6.
Do not hold and drag the belts and chains by hand.
Maintenance
1.
Continuous run time is not too long, keep using the machine.
2.
After use, clean the machine, as to avoid bacteria growth.
3.
The transmission case is packed with special grease that will last for six months of service. To add or replace grease,
it is necessary to remove the upper cover.
Note: Before maintenance, the machine must be cut off from the power supply.
Troubleshooting
Problem
Probable cause
Remedy
The mixing shaft does not rotate after
being switched on
Electric connectors are loose
Check the electric circuit, tighten those loose
connectors
Square rod trembles
Lock bolts are loose
Tighten those bolts
Temperature rise of motor is too high,
low speed
Lack of voltage
Check the supply voltage
Overload
Load it less
The noise of the transmission case is
loud
Lubrication is insufficient
Add or replace the grease
Chains are loose
Tighten the chains
The agitator knocks against the bowl
The agitator or bowl is deformed
Repair or replace deformed part
Warning: It cannot be cleaned with water directly.
