Cobalt Digital Inc CS23, Owner'S Manual

Page: 69 / 136

CS23 Owner’s Manual 3
-
9
O
PERATING
I
NFORMATION
After launching and pre-start checks and
procedures have been followed, the engine can be
started. Please refer to the propulsion unit
operator’s manual for additional starting procedure
information.
Start the engine with the shift control lever in the
NEUTRAL position. Your boat is equipped with a
neutral safety switch which will not allow engine to
be started unless the shift control levers are in the
NEUTRAL position.
Make sure:
• Control lever is in the NEUTRAL position.
• Throttle lever is at the IDLE position.
1. Turn the ignition key to START position.
Release the key immediately after the engine
starts. If the engine fails to start, refer to the
propulsion unit operator’s manual for additional
information.
2. Operate the engine at approximately 1,000
RPM and check the oil pressure gauge. If oil
pressure is not within specified range, stop the
engine immediately. Have your authorized
Cobalt dealer service the engine.
3. Make sure the water pressure gauge indicates
water pressure immediately after starting the
engine. If it does not, turn off the engine and
contact your authorized Cobalt dealer.
4. Allow the engine to warm up. Check the water
temperature gauge to be sure water
temperature remains within the specified range.
If the temperature gauge reads abnormally high,
stop the engine immediately. Check the drive unit’s
water inlets for blockage. If the inlets are open,
have your authorized Cobalt dealer service the
engine.
Shifting/Running
Follow these guidelines when shifting your boat:
• Pause in the NEUTRAL position before shifting
from FORWARD to REVERSE, or REVERSE
to FORWARD.
• Avoid shifting into REVERSE while the boat is
traveling forward at speed.
• Keep the control area clean and clear of
obstructions.
Steering
Your Cobalt boat is equipped with a tilt steering
wheel. Adjust the tilt position with the release lever.
NOTICE: Release the ignition
key after the engine starts. Do
not run the start motor for more
than 10 seconds at a time.
Failure to follow this procedure
can damage an engine and the
engine’s starter motor.
CAUTION
Avoid injury, swamping the boat or
taking water in over the transom. Go
slowly when traversing in reverse.
A
DANGER
Avoid injury or death. The steering
system is the most important system in
the entire boat from a safety standpoint.
The boat’s steering system is not
self-centering. Propeller torque, trim
setting, water condition and boat speed
affect the steering. Constant attention to
the steering system is required for safe
operation. Have the system inspected
and maintained on a quarterly basis by a
qualified service technician.