Char-Broil 463251414, Product Manual

Page: 2 / 32

2
DANGER
DANGER: Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
WARNING: Indicates a potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
CAUTION
CAUTION: Indicates a potentially hazardous situation
or unsafe practice which, if not avoided, may result in
minor or moderate injury.
TABLE OF CONTENTS
Safety Symbols
The symbols and boxes shown below explain what each
heading means. Read and follow all of the messages found
throughout the manual.
THIS GRILL IS FOR OUTDOOR
USE ONLY.
Read and follow all safety statements, assembly
instructions, and use and care directions before
attempting to assemble and cook.
INSTALLER/ASSEMBLER:
Leave this manual with consumer.
CONSUMER:
Keep this manual for future reference.
Failure to follow all manufacturer’s instructions could
result in serious personal injury and/or property
damage.
Some parts may contain sharp edges. Wear
protective gloves if necessary.
For residential use only. Do not use for
commercial cooking.
WARNING
DANGER
If you smell gas:
1. Shut off gas to the appliance
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
WARNING
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of
this or any other appliance.
WARNING
CAUTION
CAUTION
CAUTION
WARNING
CALIFORNIA PROPOSITION 65
1. Combustible by-products produced when using
this product contains chemicals known to the State
of California to cause cancer, birth defects, or other
reproductive harm.
2. This product contains chemicals, including lead
and lead compounds, known to the State of
California to cause cancer, birth defects or other
reproductive harm.
Wash your hands after handling this product.
WARNING
Do not attempt to repair or alter the
hose/valve/regulator for any “assumed” defect.
Any modification to this assembly will void your
warranty and create the risk of a gas leak and fire.
Use only authorized replacement parts supplied by
manufacturer.
Installation Safety Precautions
•
Use grill, as purchased, only with LP (propane) gas
and the regulator/valve assembly supplied. If your grill
is Dual Fuel ready, a conversion kit must be
purchased for use with natural gas.
•
Grill installation must conform with local codes, or in
their absence of local codes, with either the
National
Fuel Gas Code, ANSI Z223.1/ NFPA 54, Natural Gas
and Propane Installation Code, CSA B149.1, or
Propane Storage and Handling Code, B149.2.
• All electrical accessories (such as rotisserie) must be
electrically grounded in accordance with local codes, or
National Electrical Code, ANSI / NFPA 70 or Canadian
Electrical Code, CSA C22.1.
Keep any electrical cords
and/or fuel supply hoses away from any hot surfaces.
•
This grill is safety certified for use in the United States
and/or Canada only. Do not modify for use in any other
location. Modification will result in a safety hazard.
CAUTION
Grease Fires
• Putting out grease fires by closing the lid is
not possible. Grills are well ventilated for
safety reasons.
• Do not use water on a grease fire. Personal injury
may result. If a grease fire develops, turn knobs
and LP tank off.
• If grill has not been regularly cleaned, a grease fire
can occur that may damage the product. Pay close
attention while preheating or burning off food
residue to insure that a grease fire does not
develop. Follow instructions on General Grill
Cleaning and Cleaning The Burner Assembly to
prevent grease fires.
•
The best way to prevent grease fires is
regular cleaning of the grill.
CAUTION
Using pots larger than 6 quarts in capacity could
exceed weight limit of the side burner shelf or side
shelf, resulting in failure of grill cart components.
DANGER
• NEVER store a spare LP cylinder under or near
the appliance or in an enclosed area.
• Never fill a cylinder beyond 80% full.
If you see, smell or hear gas escaping,
immediately get away from the LP
cylinder/appliance and call your fire department. •
An over filled or improperly stored cylinder is a
hazard due to possible gas release from the safety
relief valve. This could cause an intense fire with
risk of property damage, serious injury or death.
•
For Your Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Parts Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-25
Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . 26-27
Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31