Champion 73001i-DF (EU) Owner'S Manual & Operating Instructions Download Page 11

Page: 11 / 17

MAINTENANCE AND STORAGE

Air Filter

1.  Remove the maintenance cover.
2.  Locate the air filter plastic cover.
3.  Unsnap the locking hinge on the cover.
4.  Remove the old filter.
5.  Place the new filter in the assembly.
6.  Re-snap the hinge on the air filter cover.
7.  Reinstall the maintenance cover and tighten the

cover screw securely.

Use a damp cloth to clean exterior surfaces of the
generator.
Use a soft bristle brush to remove dirt and oil.
Use an air compressor (25 PSI) to clear dirt and debris
from the generator.

Cleaning

DO NOT spray generator with water.

CAUTION

Water can contaminate the fuel system.

Adjustments

The air-fuel mixture is not adjustable. Tampering with
the governor can damage your generator and your
electrical devices and will void your warranty.

Maintenance Schedule

Follow the service intervals indicated in the following
maintenance schedule.
Service your generator more frequently when operating
in adverse conditions.

Spark Arrester

1. Allow the engine to cool completely before servicing

the spark arrester.

2. Remove the two screws holding the cover plate

which retains the end of the spark arrester to the
muffler.

3. Remove the spark arrester screen.
4. Carefully remove the carbon deposits from the spark

arrester screen with a wire brush.

5. Replace the spark arrester if it is damaged.
6. Position the spark arrester in the muffler and attach

with the two screws.

Failure to clean the spark arrester will result in
degraded engine performance.

CAUTION

MAINTENANCE AND STORAGE

Generator Maintenance

Make certain that the generator is kept clean and stored
properly. Only operate the unit on a flat, level surface in
a clean, dry operating environment. DO NOT expose the
unit to extreme conditions, excessive dust, dirt, moisture
or corrosive vapours.
Use a damp cloth to clean exterior surfaces of the
generator.
Use a soft bristle brush to remove dirt and oil.
Use an air compressor (25 PSI) to clear dirt and debris
from the generator.
Inspect all air vents and cooling slots to ensure that they
are clean and unobstructed.

DO NOT use a garden hose to clean the generator.

Water can enter the generator through the cooling
slots and damage the generator windings.

CAUTION

Disconnect the Battery

1. Remove the battery panel cover.
2. Remove the protective cover from the black/negative

battery lead.

3. Disconnect the black/negative lead from the black/

negative terminal on the battery and store the cap
screw and nut.

4. Repeat steps 1-2 for the red/positive battery lead.
5. Store the battery in a cool, dry place.

A Float Charger will maintain the battery condition
over long storage periods.

NOTE

Charge the Battery

For a generator equipped with batteries for electric
starting, proper battery maintenance and storage should
be followed. An automatic battery charger (included)
with automatic charging capability should be used to
charge the battery. Maximum charging rate should not
exceed 1.5 amps. Follow the instructions included with
the battery charger. The battery should be fully charged
at least once per month.

Generator Battery

This product is equipped with an automatic battery
charging circuit. The battery will receive charging
voltage when the engine is running. The battery will
maintain a proper charge if the unit is used on a regular
basis (about once every two weeks). If it is used less
frequently, the battery should be connected to a trickle
charger (included) or battery maintainer to keep the
battery properly charged. If the battery is not able to
start the engine, it can be started by manually pulling
the engine recoil cord. If the battery voltage is extremely
low, the charging circuit may not be able to re-charge
the battery. In this case, the battery must be connected
to a standard automotive style battery charger for
re-charging before it can be used.

*To be performed by knowledgeable, experienced owners or
Champion Power Equipment certified dealers.

Every 8 hours or daily

Check oil level

Clean around air intake and muffler

Check hoses for leaks

First 5 hours

Change oil

Every 50 hours or every season

Clean air filter

Change oil if operating under heavy load or in hot environments

Every 100 hours or every season

Change oil