2.0 Commissioning Checklist
2.1 Pre-Launch Check
1.
___ Check hoses and clamps.
2.
___ Check all through hull fittings.
3.
___ Barrier coat applied, antifouling paint applied.
4.
___ Hull sides clean, gel coat OK.
5.
___ Decks clean.
6.
___ Teak cleaned and oiled.
7.
___ Interior finished, oiled, clean.
8.
___ Cushions, carpeting, curtains - clean and in place.
9.
___ Table converts to berth OK; dinette, traditional table stows OK.
10.
___ Hatch lids present and fit OK.
11.
___ Lifelines and pulpits rigged and OK.
12.
___ Spreaders taped and drilled at base end; upper shroud wired to tip end, and taped.
13.
___ Standing rigging pinned to mast.
14.
___ Rigging lengths verified with check list in kit.
15.
___ Mast and boom inspected; cotter pins, sheaves, tangs, spreaders OK.
16.
___ Mast lights checked before mast stepped.
17.
___ Check overhead for electrical wires which may interfere with the space required to raise the
mast to its full upright position. If there are wires of any kind, anywhere near the boat, do not
raise the mast. Move boat to another location, away from any wires. Contact with wire can be
fatal.
2.2 In Water Check
2.2.1 Electrical
1.
___ Electrical equipment operational:
Running, Cabin, Bow, Anchor, Spreaders, Master
_____________________________
Outboard Engine Serial Number
______________________________
Owner's Address
Length Overall
21' - 6"
Beam
7' - 8"
Length Waterline
19' - 4"
Draft
Swing Keel Board Up
Swing Keel Board Down
Fixed Keel
2' - 0"
5' - 0"
3' - 6"
Ballast
Swing Keel
Fixed Keel
550 Lbs.
800 Lbs
Displacement
Swing Keel
Fixed Keel
2250 1bs.
2490 Lbs.
Masthead To Waterline
29.1 Ft.
Water Tank Capacity
Portable
Fuel Tank
Capacity For 6
Gallon Portable
Holding Tank
Self
Containing
Head
Berths
Sleeps (5)
Height On Cradle
8' - 9"
Head Room
Pop Top Up
Pop Top Down
5' - 7"
4' - 4"
_____________________________
Sail Number
Page 4 of 35
Catalina 22 Owner's Manual for 1987
7/21/2010
http://www.catalina22.org/manuals/mnl87/handbook.htm