Case IH FARMALL 40C, Service Manual

Page: 22 / 51

INTRODUCTION
Safety rules – Personal safety
Farmall® 40C NA
Farmall® 50C NA
General safety rules
Read this manual carefully before starting, using carrying out maintenance, refueling or performing any other type of
operation on the tractor.
Read all the safety decals on the tractor and follow the instructions thereon before starting, operating, refueling or
carrying out maintenance on the tractor. Promptly replace any decals that are damaged, lost or illegible. Clean the
decals if they are covered by mud or debris.
The tractor must only be used by responsible personnel, trained in tractor use and authorized to operate the tractor.
Use caution when operating the tractor on slopes. Raised equipment, full tanks and other loads will change the center
of gravity of the tractor. The tractor can tip or roll over when near ditches and embankments or uneven surfaces.
Avoid using the tractor in unsuitable physical conditions, stop work instead.
Never permit anyone other than the operator to ride on the tractor.
Never operate the tractor under the influence of alcohol, drugs, or while otherwise impaired.
When digging or using ground engaging attachments be aware of buried cables. Contact local utilities to determine
the locations of services.
Pay attention to overhead power lines and hanging obstacles. High voltage lines may require significant clearance
for safety.
Hydraulic oil or diesel fuel leaking under pressure can penetrate the skin, causing serious injury or infection.
• DO NOT use your hand to check for leaks. Use a piece of cardboard or paper.
• Stop engine, remove key and relieve the pressure before connecting or disconnecting fluid lines.
• Make sure all components are in good condition and tighten all connections before starting the engine or pressur-
izing the system.
• If hydraulic fluid or diesel fuel penetrates the skin, seek medical attention immediately.
• Continuous long term contact with hydraulic fluid may cause skin cancer. Avoid long term contact and wash the
skin promptly with soap and water.
• Before removing any hydraulic tubing, check that the system is not pressurized.
Do not alter the calibration of the pressure relief valves in the various hydraulic circuits (steering, hydraulic lift, auxiliary
distributors, etc.).
Keep clear of moving parts. Loose clothing, jewelry, watches, long hair, and other loose or hanging items can become
entangled in moving parts.
Wear protective equipment when appropriate.
DO NOT attempt to remove material from any part of the tractor while it is being operated or components are in motion.
Make sure all guards and shields are in good condition and properly installed before operating the tractor. Never
operate the tractor with shields removed. Always close access doors or panels before operating the tractor.
Enter and leave the tractor using the steps and handles provided. Dirty or slippery steps, ladders, walkways, and
platforms can cause falls. Make sure these surfaces remain clean and clear of debris.
A person or pet within the operating area of a tractor can be struck or crushed by the tractor or its equipment. DO
NOT allow anyone to enter the work area.
Raised equipment and/or loads can fall unexpectedly and crush persons underneath. Never allow anyone to enter
the area underneath raised equipment during operation.
47941906 16/03/2016
15