Campbell Hausfeld VT636600, Operating Instructions Manual

Page: 1 / 32

Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described.
Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or
property damage! Retain instructions for future reference.
REMINDER: Keep your dated proof of purchase for warranty purposes!
Attach it to this manual or file it for safekeeping.
IN636800AV 8/11
See Warranty on page 10 for important information about commercial use of this product.
Operating Instructions
VT636600
© 2011 Campbell Hausfeld/Scott Fetzer
Table of Contents
Description . . . . . . . . . . . . . . . . . . . . . 1
Unpacking . . . . . . . . . . . . . . . . . . . . . . 1
Safety Guidelines . . . . . . . . . . . . . . . . 1
General Safety Information . . . . . . . . 1
Introduction . . . . . . . . . . . . . . . . . . . . 3
Installation . . . . . . . . . . . . . . . . . . . . . 3
Assembly . . . . . . . . . . . . . . . . . . . . . . . 5
Operation . . . . . . . . . . . . . . . . . . . . . . 6
Maintenance . . . . . . . . . . . . . . . . . . . . 6
Troubleshooting Chart . . . . . . . . . . . . 8
Warranty . . . . . . . . . . . . . . . . . . . . . . 10
Description
Air compressor units are intended
to provide compressed air to power
pneumatic tools and operate spray
guns . The pumps supplied are oil
lubricated . A small amount of oil
carryover is present in the compressed
air stream . Applications requiring air
free of oil or water should have the
appropriate filter installed . The air
compressor unit must be mounted
as described in the instructions on
a solid floor . Any other use of these
units will void the warranty and the
manufacturer will not be responsible
for problems or damages resulting from
such misuse .
Unpacking
After unpacking the unit, inspect
carefully for any damage that may
have occurred during transit . Make sure
to tighten fittings, bolts, etc ., before
putting unit into service .
ReaD & FOllOW all InSTRUCTIOnS
SaVe TheSe InSTRUCTIOnS
DO nOT DISCaRD
GeneRal SaFeTy
Since the air compressor and other
components (material pump, spray
guns, filters, lubricators, hoses, etc .)
used, make up a high pressure pumping
system, the following safety precautions
must be observed at all times:
1 . Read all manuals included
with this product
carefully . Be thoroughly
familiar with the controls
and the proper use of the
equipment .
Safety Guidelines
This manual contains information
that is very important to know and
understand . This information is
provided for SAFETY and to PREVENT
EQUIPMENT PROBLEMS . To help
recognize this information, observe the
following symbols .
Danger indicates an
imminently
hazardous situation which, if not
avoided, WILL result in death or serious
injury.
Warning indicates a
potentially
hazardous situation which, if not
avoided, COULD result in death or
serious injury.
Caution indicates a
potentially
hazardous situation which, if not
avoided, MAY result in minor or
moderate injury.
Notice indicates
important
information, that if not followed, may
cause damage to equipment.
nOTe: Information that requires special
attention .
General Safety Information
CalIFORnIa pROpOSITIOn 65
This product or
its power cord may
contain chemicals known to the State
of California to cause cancer and birth
defects or other reproductive harm.
Wash hands after handling.
You can
create
dust when you cut, sand, drill
or grind materials such as
wood, paint, metal, concrete,
cement, or other masonry. This dust
often contains chemicals known to
cause cancer, birth defects, or other
reproductive harm. Wear protective
gear.
Breathable Air Warning
This compressor/pump is nOT
equipped and should nOT be
used “as is” to supply breathing
quality air. For any application of
air for human consumption, you
must fit the air compressor/pump
with suitable in-line safety and
alarm equipment. This additional
equipment is necessary to
properly filter and purify the air
to meet minimal specifications for
Grade D breathing as described
in Compressed Gas association
Commodity Specification G 7.1,
OSha 29 CFR 1910. 134, and/or
Canadian Standards associations
(CSa).
DISClaIMeR OF WaRRanTIeS
In the event the compressor is
used for the purpose of breathing
air application and proper in-
line safety and alarm equipment
is not simultaneously used,
existing warranties are void, and
the Manufacturer disclaims any
liability whatsoever for any loss,
personal injury or damage.
MANUAL
Stationary air
Compressor
For parts, product & service information
visit www.chpower.com