The Volvo D3 220 engine uses premium
15W-40 oil
. It’s best to check oil levels prior to
use. Be carful not to spill or overfill. Change your oil and filter at 50 hrs, then every 100
hrs after.
Note: The engine dip-stick is located on the port side, under the emergency off button.
It has a flip top lever to open.
You must re-flip to lock in place or oil will blow out.
The ZF Transmission uses ATF (automatic tranz fluid) oil for its gear lubrication and to engage
its clutch. When you go to check the oil level, make sure the engine is warm (just after its
been idling in neutral) but off. Check the oil with the dip stick pushed against the threads but
not screwed into the housing. If the oil is low, the clutch will drop out and the boat will stop.
Find the leak, repair it and refill the transmission oil. To top it off, it’s easiest to fill through
the dip stick opening with supplied funnel. Check frequently while filling , as overfilling can
damage the transmission. Change after 50 Hrs and then every 200 hrs there after, and clean
wire mesh filter with each oil change.
ENGINE & TRANSMISSION OIL
21
Summary of Contents for C 100
