MANUAL EGG COOKER/STEAMER
7
P/N 1011407 Rev. D 03/18
McDonald’s
OPERATION
Preparing Unit
1. Make sure the Timer is seated properly on the
Timer Bracket and is flush against the front of the
unit.
2. Turn the power on.
3. Check to see that all Egg Rings are seated flat on
the Grill Surface.
4. Ensure that the Egg Racks and Top Covers are in
the down position during warm-up and when not
loading or removing eggs.
5. Slide the Scrap Pans into place on both sides of
the unit.
6. The light sensor on the back of the timer senses
the activity of the Ready light on the MES-1200:
• When the unit is heating up, the Ready light
flashes which causes
HEAT
to appear on the
timer display.
• When the unit is up to temperature, the Ready
light stays on which causes
USE
to appear on
the timer display.
•
When the unit is turned off, the Ready light is
off which causes
OFF
to appear on the timer
display.
1
2
3
4
5
6
1
2
3
4
5
FIFO (First in,
first out) The
first egg in
should always
be the first egg
out
Front of Unit
To ensure proper cooking, place eggs into rings in numerical
order from 1 - 6 for the front and rear racks.
Figure 3. Egg Cooking Procedure
Front
Rack
Rear
Rack
Using the MES-1200 with the MES-1200
Timer
1. Plug in the power cord and turn the MES-1200 on.
The light sensor on the back of the timer senses
the activity of the Ready light on the MES-1200:
• When the unit is heating up, the Ready light
flashes which causes
HEAT
to appear on the
timer display.
• When the unit is up to temperature, the Ready
light stays on which causes
USE
to appear on
the timer display.
•
When the unit is turned off, the Ready light is
off which causes
OFF
to appear on the timer
display.
Refer to Figure 1 to become familiar with the Timer
interface.
The timer has two timing channels, one for the front of
the MES-1200 and one for the back.
Each timing channel has the following buttons set to the
default times shown:
• Round Front - 2 minutes 30 seconds
• Round Rear - 2 minutes 40 seconds
• Folded Front and Rear - 2 minutes
• Time 3 Front - 2 minutes 30 seconds
• Time 3 Rear - 2 minutes 40 seconds
• Time 4 Front and Rear - 2 minutes
Egg Cooking Procedure using the Timer
NOTE:
When cooking folded eggs, remove the Egg
Rack and Rings and set aside. Folded Eggs
should NOT be cooked using the Egg Rings.
1. Open the Top Covers and Egg Racks.
2. Spray clarified butter on the Grill Surface. Use 1
Spray only. Place the Egg Racks into position.
3. Wearing blue gloves, crack the round eggs into
the Egg Rings right to left and front to back. See
Figure 3.
4. Break the egg yolks with a Yolk Breaker.
5. Close the Top Covers.
6. Fill the troughs with water using stainless steel
measuring cup.
7. On the Timer, press the Round or Folded but-
ton for the section of the cooker being used (see
Figure 1):
WARNING
Be sure to wear HEAT-RESISTANT GLOVES when
removing the Egg Rack while the unit is on. Use
extreme care to avoid personal injury.
