Aeon COBRA 50 2007, Service Manual

Page: 119 / 126

ELECTRICAL
AC Output Test Connect
Meter Leads To:
AC Reading
Battery Charge Coil
Light on
White to Ground 12 VAC
Yellow to Ground 8 VAC
Battery Charge Coil
Light off
White to Ground 19 VAC
Yellow to Ground 13 VAC
NOTE: To check the charging system output further,
start the engine and perform the same tests. Voltage
should increase with increased RPM.
BATTERY
Battery Maintenance Service Notes
Battery electrolyte is poisonous. It contains sulfuric acid.
Serious burns can result from contact with skin, eyes or
clothing. Antidote:
External: Flush with water.
Internal: Drink large quantities of water or milk.
Follow with milk of magnesia, beaten egg, or vegetable
oil. Call physician immediately.
Eyes: Flush with water for 15 minutes and get prompt
medical attention.
Batteries produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using
in an enclosed space.
Always shield eyes when working near batteries.
KEEP OUT OF REACH OF CHILDREN.
CAUTION
Always wear safety glasses, rubber protective gloves
and appropriate clothing when working with batteries.
IMPORTANT: DO NOT activate cobra 50 ATV batteries
unless they will be put into service within 30 days of
activation.
Cobra 50/100 ATVs have a Low Maintenance style battery.
Do not remove the battery cap strip to check acid level or add
water once the battery have been activated. Perform the proper
battery tests and charge or replace the battery as required.
New batteries must be fully charged before use or battery life
will be significantly reduced (10-30% of the battery’s full
potential).
NOTE: DO NOT use a constant high-amperage
battery charger to charge this style of battery. Use a
low-amperage charger capable of charging voltage
that is 1/10 of the battery amp-hour rating.
8.12