Zipper Mowers ZI-HS7, Руководство по эксплуатации

Страница: 23 / 27

23
The hydraulic system is a closed system consisting of an oil tank, an oil pump and of control valves. Too
low an oil level can damage the pump. The oil level should not be lower than 1 – 2 cm above the lower
surface of the oil tank.
Change the oil completely once per year.
 Ensure that no foreign particles will get into the oil tank.
 Properly dispose of the waste oil after each oil change.
 Allow your log splitter to run idle for a few minutes after each oil change before you place it into
operation again.
The following oil grades are suitable for this log splitter:
SHELL Tellus 22
MOBIL DTE 11
ARAL Vitam GF 22
BP Energol HLP-HM 22
2.14 Troubleshooting and Fault Clearance
Problem Possible Cause Remedy
5. Motor does not start.
1.1 No power in wall
socket.
1.1 Check fuse box.
1.2 Extension cable
defective.
1.2 Unplug, check and use new one, if
necessary.
1.3 Wrong supply,
400 V, three-phase
current.
1.3 5-pole plug with 1.5 mm diameter.
1.4 Switch defective. 1.4 Have it checked by electrician.
6. Wrong motor di-
rection.
2.1 Wrong polarity.
2.1 Change polarity using a screwdriver
(electrician).
2.2 Change polarity (electrician).
7. Splitter not movIng
although motor is run-
ning.
3.1 Valve not opened,
caused by loose con-
nection.
3.1 Tighten loose parts.
3.2 Oil level too low. 3.2 Replenish oil.
8. Splitter working, how-
ever, with untypical
noise and vibration.
4.1 Oil level too low. 4.1 Replenish oil.
2.15 Disposal
Do not dispose your ZI-HS7 in the residual waste! Contact your local authorities for
information about best available disposal possibilities in your area. Drain fuel from the
fuel tank completely before disposing the machine. Disaggregate the machine into its
components before disposing them.