Wallenstein WX520, Руководство оператора

Страница: 29 / 40

WX520 / WX520L / WX520T
Log Splitter
Service and Maintenance
29
9.2.3 Engine Fuel
For complete fuel information and use at high altitudes, see
the engine manufacturer's manual.
Fuel must meet the following specifications:
• Clean, fresh, unleaded gasoline.
• Minimum of 87 octane / 87 AKI (91 RON).
• Gasoline with up to 10% ethanol (gasohol) is acceptable if
the fuel is fresh (less than three months old).
If the machine will be in storage for longer than three months,
replace the fuel with one of the following fuel types:
• An alkylate fuel
• An engineered fuel that is high octane, ethanol-free, and
formulated with power detergent to prevent the buildup of
insoluble solids (deposits).
For instructions, see Add Fuel to the Engine on page 23 .
9.2.4 Grease
Use an SAE multi-purpose high temperature grease with extreme
pressure (EP) performance. An SAE multipurpose lithium-based
grease is an acceptable substitute.
9.2.5 Hydraulic Fluid
Use Dexron® III automatic transmission fluid (ATF) for all
operating conditions.
The following ATFs are acceptable substitutes:
• Dexron VI
• Mercon ®
.
9.3 Maintenance Schedule
Perform maintenance procedures at time shown or hour
interval, whichever comes first.
As Required
Check the condition of all hydraulic lines, hoses and fittings.
Replace any that are damaged.
Remove any entangled material from splitter.
Check that all fasteners are tight.
Every 8 hours or Daily
Check fuel level See page 23
Check engine oil level. See page 22
Clean the engine air-intake grille —
Every 40 hours or Annually
Check hydraulic fluid level. See page 23
Inspect hydraulic fluid quality See page 23
Grease frame slide, hinges, pivot
points
See page 30
Every 100 hours or Annually
Grease axle bearings See page 30
Check tire pressure
See rating on tire
sidewall
Change hydraulic fluid and filter See page 31
Clean machine. Remove debris
and entangled material.
—
Change fuel filter See engine manual
Every 200 hours or Annually
Clean the engine air filter See page 32
Change the engine oil See page 22
Every 600 hours or Every 6 Years
Change the engine air filter See page 32