State Water Heaters SUF 130 300, Инструкция по эксплуатации

Страница: 21 / 76

21
SURYLGH DQ DGHTXDWH VXSSO\ RI IUHVK DLU WKH ZDWHU KHDWHU
PXVWEHLQVWDOOHGLQD'LUHFW9HQWFRQ¿JXUDWLRQ
2.
,I WKH ZDWHU KHDWHU LV WR EH LQVWDOOHG LQ D EHDXW\ VKRS
EDUEHU VKRS FOHDQLQJ HVWDEOLVKPHQW D ODXQGU\ ZLWK GU\
FOHDQLQJHTXLSPHQWRUDQ\VSDFHZLWKFRQWDPLQDWHGDLULWLV
LPSHUDWLYH WKDW WKH ZDWHU KHDWHUV EH LQVWDOOHG LQ D 'LUHFW
9HQW FRQ¿JXUDWLRQ VR WKDW DOO DLU IRU FRPEXVWLRQ LV GHULYHG
IURPWKHRXWGRRUDWPRVSKHUH
3.
7KHYHQWDQGLQWDNHDLUSLSLQJPXVWWHUPLQDWHRXWGRRUV
4.
7KHPLQLPXPFOHDUDQFHIURPFRPEXVWLEOHPDWHULDOVIRUWKH
YHQWH[KDXVWDQGLQWDNHDLUSLSLQJVKDOOEHLQFKHV9HQW
SLSLQJSDVVLQJWKURXJKDFRPEXVWLEOHZDOORUFHLOLQJPXVWEH
DFRQWLQXRXVUXQQRMRLQWV
5.
7KHZDWHUKHDWHUPXVWEHSURWHFWHGIURPIUHH]LQJGRZQGUDIWV
GXULQJVKXWGRZQSHULRGV
6.
7KHYHQWH[KDXVWSLSHPXVWQRWEHFRPELQHGRUFRQQHFWHG
WRDQ\RWKHUDSSOLDQFH¶VYHQWV\VWHPRUFKLPQH\
7.
7KH LQWDNH DLU SLSH PXVW QRW EH FRPELQHG RU FRQQHFWHG WR
DQ\RWKHUDSSOLDQFH¶VLQWDNHDLUSLSLQJ
8.
/RFDWHWKHZDWHUKHDWHUZKHUHWKHYHQWH[KDXVWDQGLQWDNH
DLUSLSLQJZLOOUHPDLQZLWKLQWKHPD[LPXPHTXLYDOHQWOHQJWKV
DOORZHG6HH9HQWLQJ5HTXLUHPHQWVRQSDJH
9.
'RQRWLQVWDOOWKHYHQWRULQWDNHDLUSLSLQJLQDPDQQHUWKDWZLOO
DOORZZDWHUWREHWUDSSHGLQWKHSLSLQJ
10.
9HQWSLSHVPXVWEHSLWFKHGDPLQLPXPRIDLQFKSHUIRRW
EDFNWRWKHZDWHUKHDWHUWRDOORZGUDLQDJHRIFRQGHQVDWH
11.
'RQRWDQFKRUWKHYHQWRULQWDNHDLUSLSHGLUHFWO\WRIUDPHG
ZDOOVÀRRUVRUFHLOLQJVXQOHVVUXEEHULVRODWLRQSLSHKDQJHUV
DUHXVHGWRSUHYHQWYLEUDWLRQQRLVHIURPEHLQJWUDQVPLWWHG
12.
8VHRQO\DSSURYHGYHQWLQWDNHDLUSLSHVL]HVDQGPDWHULDOV
See Venting Requirements on page 22.
13.
8VH RQO\ IDFWRU\ VXSSOLHG YHQW DQG LQWDNH DLU RU FRQFHQWULF
terminations. See the Venting Requirements on page 22.
14.
'R QRW ORFDWH WKH YHQW H[KDXVW RU LQWDNH DLU WHUPLQDWLRQV
ZKHUH WKH\ ZRXOG EH REMHFWLRQDEOH GXH WR QRLVH DW WKH
WHUPLQDWLRQV7KLVLQFOXGHVORFDWLRQVFORVHWRRUDFURVVIURP
ZLQGRZVDQGGRRUV
15.
'LUHFWYHQWLQJLQWRGHDGDLUVSDFHVVXFKDVDOOH\VDWULXPV
DQG LQVLGH FRUQHUV FDQ FDXVH UHFLUFXODWLRQ RI ÀXH JDVHV
5HFLUFXODWLRQ RI ÀXH JDVHV ZLOO FDXVH VRRWLQJ SUHPDWXUH
IDLOXUH RI WKH KHDW H[FKDQJHU DQG LFLQJ RI WKH FRPEXVWLRQ
DLU LQWDNH GXULQJ VHYHUH FROG ZHDWKHU 7R SUHYHQW WKH
UHFLUFXODWLRQ RI ÀXH JDVHV PDLQWDLQ DV PXFK GLVWDQFH DV
SRVVLEOHEHWZHHQWKHLQWDNHDLUDQGYHQWWHUPLQDWLRQV
16.
'RQRWORFDWHWKHYHQWWHUPLQDWLRQRYHUDSXEOLFDUHDZKHUH
FRQGHQVDWHRUYDSRUFDQFDXVHDQXLVDQFHRULFHKD]DUG
17.
(QVXUHWKHVFUHHQVLQWKHIDFWRU\VXSSOLHGWHUPLQDWLRQVDUH
VHFXUHO\LQVWDOOHGWRSUHYHQWEORFNDJHLQWKHYHQWV\VWHP
18.
6WUHVVOHYHOVLQSLSH¿WWLQJVFDQEHVLJQL¿FDQWO\LQFUHDVHGE\
LPSURSHU LQVWDOODWLRQ ,I ULJLG SLSH FODPSV DUH XVHG WR KROG
WKHSLSHLQSODFHRULIWKHSLSHFDQQRWPRYHIUHHO\WKURXJKD
ZDOOSHQHWUDWLRQWKHSLSHPD\EHVWUHVVHGRUKLJKWKHUPDO
VWUHVVHVPD\EHIRUPHGZKHQWKHSLSHKHDWVXSDQGH[SDQGV
,QVWDOODFFRUGLQJO\WRPLQLPL]HVXFKVWUHVVHV
19.
&DUHIXOO\UHDGWKH9HQWLQJ5HTXLUHPHQWVRQSDJHDQGWKHQ
SURFHHGWRWKH9HQWLQJ,QVWDOODWLRQ6HTXHQFHRQSDJH
VENTING INSTALLATION
Breathing carbon monoxide can cause brain damage or death.
Always read and understand the instruction manual.
Install vent system in accordance with codes.
Do not operate water heater if flood damaged.
Special consideration must be taken with installations
above 10,000 feet (3,048 m) refer to high altitude
section of this manual.
Breathing Hazard - Carbon Monoxide Gas
,
,
Do not operate if soot buildup.
,
Do not obstruct water heater air intake with insulating
jacket or blanket.
,
Do not place chemical vapor emitting products near
water heater.
,
Gas and carbon monoxide detectors are available.
,
Never operate the heater unless it is vented to the
outdoors and has adequate air supply to avoid risks
of improper operation, fire, explosion or asphyxiation.
,
Analyze the entire vent system to make sure that
condensate will not become trapped in a section of
vent pipe and therefore reduce the open cross
sectional area of the vent.
,
,
1HYHURSHUDWHWKHZDWHUKHDWHUXQOHVVLWLVYHQWHGWRWKHRXWGRRUV
7KHLQVWUXFWLRQVLQWKLVVHFWLRQRIWKHPDQXDOPXVWEHIROORZHG
WRDYRLGFKRNHGFRPEXVWLRQRUUHFLUFXODWLRQRIÀXHJDVHV6XFK
FRQGLWLRQV FDXVH VRRWLQJ RI WKH FRPEXVWLRQ FKDPEHU EXUQHUV
DQGÀXHWXEHVDQGFUHDWHVDULVNRIDVSK\[LDWLRQ
GENERAL VENTING INFORMATION
7KH ZDWHU KHDWHUV FRYHUHG LQ WKLV PDQXDO DUH RSHUDWLRQDOO\
HTXLYDOHQW WR &DWHJRU\ ,9 DSSOLDQFHV DQG PD\ EH LQVWDOOHG LQ
HLWKHUD3RZHU9HQWRU'LUHFW9HQWFRQ¿JXUDWLRQ
CATEGORY IV APPLIANCE
&DWHJRU\ ,9 DSSOLDQFHV RSHUDWH ZLWK D SRVLWLYH YHQW H[KDXVW
VWDWLF SUHVVXUH DQG ZLWK YHQW JDV WHPSHUDWXUHV ORZ HQRXJK WR
SURGXFHFRQGHQVDWHLQWKHYHQWSLSLQJ
POWER VENT CONFIGURATION
3RZHU 9HQW FRQ¿JXUDWLRQV GHULYH DOO FRPEXVWLRQ DLU IURP WKH
URRP ZKHUH WKH\ DUH LQVWDOOHG DQG GLVFKDUJH DOO ÀXH JDVHV WR
WKH RXWGRRU DWPRVSKHUH WKURXJK D VHDOHG YHQW H[KDXVW SLSH
3RZHUYHQWFRQ¿JXUDWLRQVKDYHRQHYHQWSLSHFRQQHFWHGWRWKH
ZDWHUKHDWHUZKLFKFDQEHWHUPLQDWHGLQDYHUWLFDORUKRUL]RQWDO
DUUDQJHPHQW6HH)LJXUHDQG)LJXUHRQSDJH
DIRECT VENT CONFIGURATION
'LUHFW9HQWFRQ¿JXUDWLRQVGHULYHDOOFRPEXVWLRQDLUGLUHFWO\IURP
WKH RXWGRRU DWPRVSKHUH WKURXJK D VHDOHG LQWDNH DLU SLSH DQG
GLVFKDUJH DOO ÀXH JDVHV WR WKH RXWGRRU DWPRVSKHUH WKURXJK D
VHDOHGYHQWH[KDXVWSLSH'LUHFW9HQWFRQ¿JXUDWLRQVKDYHWZR
SLSHV FRQQHFWHG WR WKH ZDWHU KHDWHU RQH YHQW SLSH DQG RQH
LQWDNH DLU SLSH 'LUHFW 9HQW FRQ¿JXUDWLRQV FDQ EH WHUPLQDWHG
LQRQHRIVL[GLIIHUHQWDUUDQJHPHQWV6HH)LJXUHRQSDJH
WKURXJK)LJXUHRQSDJH
GENERAL VENTING INSTRUCTIONS
7KHVHLQVWUXFWLRQVPXVWEHIROORZHGRQDOOLQVWDOODWLRQV
1. DO NOT
LQVWDOOWKHZDWHUKHDWHULQD3RZHU9HQWFRQ¿JXUDWLRQ
XQOHVV WKHUH LV DGHTXDWH VXSSO\ RI IUHVK DLU VHH $LU
5HTXLUHPHQWVRQSDJH,IWKHLQVWDOODWLRQVSDFHGRHVQRW