SJIII Series E -
The CONVENTIONALS
118931AH
May 2002
SECTION 2, Page 22
Battery Service And Charging
Procedures
Battery Service
Warning
Explosion Hazard
Keep flames and sparks away.
DO NOT
smoke near
batteries.
Caution
Contact with electrolytic acid can cause skin irritation
and damage clothing. Wear a protective apron, gloves
and goggles when working with batteries.
First Aid
Immediately flush eyes with cold water if electrolytic
acid is splattered into them. Seek medical attention if
discomfort continues.
Servicing the Batteries
1.
Turn Emergency Battery Disconnect Switch to
“OFF” position.
2.
Check battery case for damage.
3.
Check battery fluid level in each battery. If plates
are not covered by at least 1/2” (13mm) of
solution, add distilled or demineralized water.
4.
Clean battery terminals and cable ends
thoroughly with a terminal cleaning tool or wire
brush.
5.
Make sure all battery connections are tight.
6.
Replace any battery that is damaged or incapable
of holding a lasting charge.
7.
Do not use any batteries other than flooded lead-
acid batteries of the proper AH rating.
Battery Charging Procedures
Warning
Explosion Hazard
Chargers can ignite flammable materials and vapors.
DO NOT
use near fuels, grain dust, solvents or other
flammable
Warning
Shock Hazard
To reduce the risk of electrical shock, the charger
must only be connected to properly grounded single
phase outlet. The AC circuit protection should not
exceed 15 amperes. The extension cord used must
be a three wire grounded cord of at least 14 AWG.
DO NOT
use an extension cord longer than 25 feet
(7.6m). Inspect AC charger’s receptacle for the
presence of water from washing or storage. Dry
thoroughly prior to use.
1.
Check for a firm AC connection at the charger
receptacle. Connect the charger cord to the AC
wall plug to turn the charger on. Refer to charger
nameplate for voltage requirements.
2.
Charge batteries.
DO NOT
leave charger
unattended for more than two consecutive days.
Severe overcharging and battery damage will
result if charger fails to turn off.
3.
Disconnect charger from external power source.
Содержание SJIII 6826E
Страница 26: ...www skyjackinc com ELEVATING THE WORLD ...
