Senci SC4000C, Инструкция по эксплуатации, Страница: 16 / 17

NOTICE: SPECIAL TOOLS WILL BE USED WHEN TIGHTEN THE CYLINDER HEAD SCREWS
8.1.6 Check the nozzle, high pressure pumps, etc.
8.1.7 Adjust the inlet and exhaust valve clearance.
8.1.8 Replace piston rings
NOTICE: DO NOT EXPOSE SKIN IN FUEL SPRAY WHEN OPERATION. FUEL CAN PENETRATE SKIN
AND CAUSE BODY HARM.KEEP AWAY FROM THE NOZZLE WHEN MEASUREING FUEL INJECTOR
ATOMIZATION SITUATION.
8.1.9 The GENERATOR use 12V storage ba ery. Check ba ery before start. Replace it if it is
damaged.
8.2 THE MAINTENANCE OF THE LONG TERM STORAGE
If the generator will be stored for long
the following opera must be conducted.
8.2.1 Run generator for 15 minutes, then stop it.
8.2.2 Discharge the oil when the generator is s ll hot, then add new oil to
specifi ed height.
8.2.3 Unscrew out the oil plug on the cylinder head cover, and add 2ml lubrica oil, then ht
the oil plug.
8.2.4 Maintenance of start part
(1) Recoil start
Keep the fuel switch in the "OFF"
, press the reducing handle and don't loosen, pull the
st handle 2-3 es (not start diesel generator).
(2) Electrical start
Keep the fuel switch in the “OFF”
press the reducing handle and turn star ng key for 2-3
seconds, but don’t start the generator.
8.2.5 Pull out the reducing handle, pull out the recoil start slowly when feel resistance.
8.2.6 Remove the storage ba ery from the generator in order to maintain monthly. To keep the
ba ery voltage between 12-14V when storage, do not store the ba ery when the ba ery voltage
is lower than 10.8V to avoid damage.
8.2.7 Clean the generator and store it in a dry place.
CHECKING AND TROUBLESSHOOTING
9.1 CHECKING AND TROUBLESSHOOTING
Failure cause troubleshoo ng
diesel fuel shortage add diesel fuel
Fuel handle is not in the “ON” turn the fuel handle to the “ON” po
High pressure pump, spray nozzle do not Overhaul of high-pressure pump, spray nozzle
spray or spray too li le and to adjust in injector testbed
Governor is not in the “RUN” turn the governor to the “RUN”
Check the oil level of the lubrica oil the oil amount is between the “higher limit” and
“lower limit”
14