Purple Line®
Page 2
Ref: CM-UM-0115-Rev.C AUS
Thank you for choosing a Purple Line® caravan mover. This has been produced according to very high standards and
has undergone careful quality control procedures. Simply by using the remote control you can move your caravan
effortlessly into any position required within operating guidelines.
Before proceeding with installation and starting to use the mover, please read this manual very carefully and be aware of
all the safety instructions! The owner of the caravan will always be responsible for correct use. Keep this manual inside
your caravan for future reference.
This User Manual covers three models of Purple Line® Caravan Mover: Model No. EGO400 and Model No. EGO130;
any installation or operational differences between the two models are detailed where appropriate. The caravan mover
consists of two 12V motor-powered rollers, a 12V electronic control box and a remote control. To function, the motor-
powered rollers must be engaged against the tyres of your caravan. The supplied cross actuation device enables you to
engage both rollers at the same time from one side of your caravan. Once this is done the mover is ready for operation.
The remote control will allow you to move your caravan in any direction.
The chassis clamps and chassis plates provided are suitable for fitment onto most standard caravan chassis. Please
refer to Fig.18 for reference on dimensions and clearances BEFORE you proceed any further with installation. The fixings
provided are also suitable for most European type chassis and will not normally require the use of the chassis plates (37)
and will, instead, fit straight onto the lip of an ‘L’ profile or ‘U’ profile chassis (please refer to Fig.18A for reference).
* Average Current Consumption readings when using an approx. 1100Kg single axle caravan on a hard, level surface.
* Maximum Current Consumption readings when using an approx. 1100Kg single axle caravan ascending a 1:4 (25%)
gradient.
These symbols identifiy important safety precautions.
They mean CAUTION! WARNING! SAFETY FIRST! IMPORTANT INFORMATION!
Before starting installation under the caravan
:
DO
check that the caravan is disconnected from the battery supply and the mains electrical supply.
DO
only use adapters and accessories that are supplied or recommended by the manufacturer.
DO
check that the tyres are not over worn (fitting to new or nearly new tyres is the best option).
Specifications
Installation Safety Guidelines
Important Safety Instructions
Read this User Manual carefully before installation and use. Failure to comply with
these rules could result in serious injury or damage to property.
Introduction
Fitting Guidelines
Model Number
EGO400
EGO130
Operational Voltage
12 Volt DC
12 Volt DC
Average Current Consumption*
25 Ampere (approx)
25 Ampere (approx)
Maximum Current Consumption*
76 Ampere (approx)
76 Ampere (approx)
Speed
12cm per sec. (approx)
12cm per sec. (approx)
Approx. Net Weight (inc. all fixings & accessories)
37 Kg
37 Kg
Safe Working Load (SWL) Twin Motor/Quad Motor
2250Kg/3500Kg
2250Kg/3500Kg
Minimum Width (caravan/trailer)
1800mm
1800mm
Maximum Width (caravan/trailer)
2500mm
2500mm
Power Source (caravan leisure battery)
12V
12V
PL CM manual AU 01-15.indd 2
14/1/15 10:43:43