OPERATION INSTRUCTIONS
Before Starting
WARNING: Check hoses, trigger guns, fittings, and fuel connections daily for signs of wear, cracks and looseness,
and replace as required.
1. Read all manuals provided with this pressure washer. Become familiar with location and function of all operating and safety
controls.
2. Connect water supply hose to the standard garden hose connector. The water source and supply hose must be capable of
providing 30 LPM.
3. Fill fuel tank. Use Diesel
DO NOT USE PETROL, CRANKCASE OIL RESIDUALS OR WASTE OIL.
4. Check pump oil level.
5. If detergents are to be used, only use detergents intended for pressure washers. Follow instructions on the detergent con
-
tainer.
IMPORTANT: If the pressure washer has not been used for an extended period of time, remove the nozzle from the
end of the wand and turn on water supply. Allow water to run from the end of the wand until clear.
IMPORTANT: The trigger gun provided with this pressure washer is equipped with a manual trigger lock to prevent
accidental operation of the trigger gun. The trigger lock should be used whenever the trigger gun is not in use.
To Start
IMPORTANT: The water must be turned on before starting. Running the pump dry will cause damage to pump seals
and void warranty.
IMPORTANT: DO NOT allow the machine to run in bypass for more than 10 minutes at any one time or damage to
pump may occur.
1. Turn water on.
2. Hold gun firmly, squeeze trigger of trigger gun and turn engine key switch to ON. Allow air to purge from system.
3. If HOT water is desired, press the burner button ON. Adjust thermostat to desired temperature. The burner
will fire immediately with a small puff of smoke. If smoke continues refer to the Troubleshooting Guide in this manual. When
the trigger gun is closed the burner will turn off.
To Stop
1. If detergents were used, draw clear water through the detergent line to purge detergent.
2. If burner was used, turn off burner button and allow pump to run cold water through coil.
3. Turn the key on the engine to OFF.
4. Turn OFF water supply.
5. Squeeze trigger gun open to relieve system pressure.
PAGE
4
PHONE: 1800 790 915
PUMPS AUSTRALIA PTY LTD
USER MANUAL
PHONE: 1800 790 915
PUMPS AUSTRALIA PTY LTD
