probst 51700004, Руководство по эксплуатации

Страница: 45 / 77

×
×
−
×
TAKING CARE OF UNEXPECTED PROBLEMS
ENGINE WILL
NOT START Possible Cause Correction
ENGINE LACKS
POWER Possible Cause Correction
FUSE REPLACEMENT (applicable types)
ENGLISH
FUSE
COVER
ENGINE SWITCH
REAR COVER
6 12 mm
SPECIAL SCREW
FUSE
15
Remove the 6 12 mm special screw from the rear cover of the
engine switch box, and remove the rear cover.
The electric starter relay circuit and battery charging circuit are
protected by a fuse. If the fuse burns out, the electric starter will
not operate. The engine can be started manually if the fuse burns
out, but running the engine will not charge the battery.
Remove the fuse cover, then pull out and inspect the fuse.
If the fuse is burnt out, discard the burnt-out fuse. Install a new
fuse with the same rating as the one that was removed, and
reinstall the cover.
If you have questions regarding the rating of the original fuse,
contact your Honda servicing dealer.
Never use a fuse with a rating greater than the one originally
equipped with the engine. Serious damage to the electrical
system or a fire could result.
Reinstall the rear cover. Install the 6 12 mm screw and tighten
it securely.
Frequent fuse failure usually indicates a short circuit or an
overload in the electrical system. If the fuse burns out frequently,
take the engine to a Honda servicing dealer for repair.
Electric
starting
(applicable
types):
Check battery
and fuse.
Check control
positions.
Check engine
oil level.
Check fuel.
Remove and
inspect spark
plug.
Take engine to
an authorized
Honda
servicing
dealer, or refer
to shop
manual.
Battery
discharged.
Fuse burnt out.
Fuel valve OFF.
Choke open.
Engine switch
OFF.
Engine oil level
low (Oil Alert
models).
Out of fuel.
Bad fuel; engine
stored without
treating or
draining
gasoline, or
refueled with
bad gasoline.
Spark plug faulty,
fouled, or
improperly
gapped.
Spark plug wet
with fuel
(flooded engine).
Fuel filter
restricted,
carburetor
malfunction,
ignition
malfunction,
valves stuck, etc.
Recharge battery.
Replace fuse
(p. 15).
Move lever to ON
position.
Move lever to
CLOSED position
unless the engine
is warm.
Turn engine switch
to ON position.
Fill with the
recommended oil
to the proper level
(p. 9).
Refuel (p. 8).
Drain fuel tank and
carburetor (p. 14).
Refuel with fresh
gasoline(p. 8).
Gap or replace
spark plug (p. 12).
Dry and reinstall
spark plug. Start
engine with
throttle lever in
MAX. position.
Replace or repair
faulty components
as necessary.
Check air filter.
Check fuel.
Take engine to
an authorized
Honda
servicing
dealer, or refer
to shop
manual.
Filter element(s)
restricted.
Bad fuel; engine
stored without
treating or
draining
gasoline, or
refueled with
bad gasoline.
Fuel filter
restricted,
carburetor
malfunction,
ignition
malfunction,
valves stuck, etc.
Clean or replace
filter element(s)
(p. 11
12).
Drain fuel tank and
carburetor (p. 14).
Refuel with fresh
gasoline (p. 8).
Replace or repair
faulty components
as necessary.
1.
2.
3.
4.
5.
1.
2.
3.
1.
2.
3.
6.
11/07/04 17:19:39 32Z4M600_015