NON-MECHANICAL
FLOW EQUALIZATION
The patented design of the Bio-Kinetic system provides
non-mechanical flow equalization for the Singulair
wastewater treatment plant. Equalization reduces
incoming hydraulic surges (e.g. typical shower of 10
minutes duration, bathtub discharge of 5 minutes duration,
clothes washer discharge of 2 minutes duration and
dishwasher discharge of 2 minutes duration) throughout the
system. The flow equalization provided by the Bio-Kinetic
system causes wastewater to be held upstream of the final
outlet during hydraulic surges, which preserves treatment
integrity and enhances system operation. The actual rate
of equalization varies and depends upon specific loading
patterns and the duration of each flow surge. At the design
loading pattern used during the NSF/ANSI Standard 40
performance evaluation, the Singulair system equalizes
all flow an average of 50%. As a result, hydraulic surges
and periods of high wastewater flow are automatically
reduced to protect the environment and all treatment plant
processes on a demand use, as needed, basis.
BLUE CRYSTAL
®
RESIDENTIAL
DISINFECTING TABLETS
If local regulations require, an initial supply of Blue Crystal
disinfecting tablets will be placed in the Bio-Kinetic system
chlorine feed tube(s) at system start-up. Manufactured
from calcium hypochlorite, Blue Crystal disinfecting tablets
provide effective, economical bacteria killing power. Liquid
entering the Bio-Kinetic system contacts the installed
Blue Crystal disinfecting tablets, just downstream of the
equalization ports. A fully charged feed tube will last
an average of six months. During each semi-annual
inspection, your Singulair service provider will check
system operation and install tablets as needed.
NOTE:
USEPA guidelines state “On the average,
satisfactory disinfection of secondary wastewater effluent
can be obtained when the chlorine residual is 0.5 ppm after
15 minutes contact.” Retention time must comply with the
controlling regulatory jurisdiction.
BIO-NEUTRALIZER
®
DECHLORINATION
TABLETS
In environmentally sensitive areas, regulations may require the
use of Bio-Neutralizer dechlorination tablets. Manufactured
to chemically neutralize both free and combined chlorine,
Bio-Neutralizer dechlorination tablets provide consistent
reduction or elimination of chlorine residual without
unnecessarily reducing the level of dissolved oxygen in
the treatment system effluent. As liquid passes through
the final discharge zone of the Bio-Kinetic system, the
flow contacts the tablets and residual chlorine is removed
from the system effluent. A fully charged feed tube will
last an average of six months. During each semi-annual
inspection, your Singulair service provider will check
system operation and install tablets as needed.
CAUTION:
The improper handling of Blue Crystal and
Bio-Neutralizer tablets may cause personal injury or
property damage. Keep out of the reach of children and
do not allow the tablets or feed tubes to contact skin,
eyes, or clothing. Blue Crystal tablets may be fatal if
swallowed and tablet dust is irritating to the eyes, nose
and throat. Do not handle the tablets or feed tubes
without first carefully reading the product container
label, MSDS information and the handling and storage
instructions. Mixing of chemicals may cause a violent
reaction leading to fire or explosion. For additional
information about Blue Crystal and Bio-Neutralizer
tablets contact your Singulair service provider.
ACCESS RISERS AND COVERS
Concrete access covers are recommended and must be
secured after each service visit. A concrete plug should
be installed in the access openings of the tank to prevent
accidental entry. Access covers should be inspected during
service visits and replaced as necessary. If plastic risers
and/or covers are utilized, they must be approved for your
application and secured as instructed by the manufacturer.
Refer to state and local regulations for applicable codes
that may apply to your installation.
DANGER: Make sure your service provider does not
leave access risers uncovered or partially covered.
Failure to properly secure access covers and safety
nets could result in bodily injury, illness or death. Do
not allow children to play on or around the treatment
system. Riser safety nets are available from Norweco
for concrete or plastic risers.
NO OWNER MAINTENANCE
The Singulair system is inspected and serviced by a
local, factory-trained service provider, therefore, no owner
maintenance is required during the warranty period. The
Singulair system does not require pumping as often as
a septic tank. Under normal use only the pretreatment
chamber should be pumped. How often pumping is
necessary depends on system use. The local Singulair
service provider will inspect the aeration chamber contents
and plant effluent at six month intervals to determine if the
pretreatment chamber is discharging excessive solids.
Every three years, the pretreatment chamber should be
inspected. The pretreatment chamber will normally require
pumping at three to five year intervals. Contact your
local service provider prior to tank pumping for complete
information on removal of equipment, access to individual
chambers, coordination of services and proper disposal
of tank contents.
If a period of intermittent use, or an extended period of
non-use of the system is anticipated, contact your service
provider for instructions. Your service provider has detailed
service instructions and has been factory-trained in
troubleshooting procedures. Contact your service provider
if you require service or tank pumping information.
