SD Series
Operating & Safety Instructions
USA 03/12
8
2.1.9
Only operate the Niftylift on a firm, level surface.
2.1.10
Never position any part of the Niftylift within 12ft of any electrical power line, conductor or similar not
exceeding 66kV. (Minimum span 125m) Other distances for increased voltages and different spans
are given in NZECP 34:1993
THIS MACHINE IS NOT INSULATED.
If in doubt, contact the appropriate authorities
2.1.11
On entering the basket, ensure that the drop down entry bar is closed afterwards.
2.1.12
Use of an approved safety belt and lanyard, hard hat and appropriate safety clothing is mandatory.
Fasten harness to designated harness securing points within the basket and do not remove until leaving
the basket whilst in the stowed position.
2.1.13
Always remain standing within the basket. Do not attempt to increase your height
or reach by standing and/or climbing on the basket guard rails or any other object.
KEEP YOUR FEET ON THE BASKET FLOOR
. Do not sit, stand or climb on the
guard rail, mid rail or boom linkage. Use of planks, ladders or any other devices on
the Niftylift for achieving additional height or reach shall be prohibited.
2.1.14
Do not use the basket levelling system to artificially increase the outreach of the Niftylift. Never use
boards or ladders in the basket to achieve the same result.
2.1.15
Do not use the basket to lift overhanging or bulky items which may exceed the maximum capacity or
carry objects which may increase the wind loading on the basket.
2.1.16
The Niftylift shall not be operated from a position on trucks, trailers, railway cars, floating vessels,
scaffolds or similar equipment unless the application is approved in writing by Niftylift Ltd in Great
Britain.
2.1.17
Before lowering or boom rotating, always check below and around the basket to ensure that the area is
clear of personnel and obstructions. Care should be taken when boom rotating out into areas where
there may be passing traffic. Use barriers to control traffic flow or prevent access to the machine.
2.1.18
Stunt driving and horseplay, on or around the Niftylift, shall not be permitted
.
2.1.19
When other moving equipment and vehicles are present, special precautions shall be taken to comply
with local ordinances or safety standards established for the work place. Warnings such as, but not
limited to flags, roped off areas, flashing lights and barricades shall be used.
2.1.20
Before and during driving while the booms is elevated the operator shall maintain a clear view of the
path of travel, maintain a safe distance from obstacles, debris, drop offs, holes, depressions, ramps
and other hazards to ensure safe elevated travel. Maintain a safe distance from overhead obstacles.
2.1.21
Under all travel conditions the operator shall limit travel speed according to conditions of ground
surface, congestion, visibility, slope, location of personnel and other factors causing hazards of
collision or injury to personnel.
