Newstripe NewRider 1700 HPA, Руководство пользователя

Страница: 19 / 26

NewRider™ 1700 HPA Airless Ride-on Sprayer
ALWAYS wear safety goggles or protective eye-wear when operating the unit !
NewRider™ 1700 HPA Manual / 4026.0916 Page 15 of 16
Transaxle service and maintenance
Fluid change
This transaxle is designed with an external filter for ease of maintenance. To ensure constant fluid quality levels and
longer life, an initial oil and filter change at 75-100 hours, then every 400 hours thereafter is recommended.
The following procedure can be performed with the transaxle installed in the vehicle, and the vehicle on level ground.
Apply the bypass valve and lock the vehicle parking brake.
1. Remove the three 1/4” filter guard screws and filter guard. Clean any loose debris from around the perimeter of the
filter. See filter and filter guard removal Page 15 of this manual.
2. Place an oil drain pan (12” or more diameter and 8 qt. capacity is optimal) beneath the oil filter. Remove the oil filter
from the transaxle.
3. After the oil has drained, wipe the filter base surface off and apply a film of new oil to the gasket of the new
replacement filter (Newstripe part number 10003778/Hydro-Gear part number 52114).
4. Install the new filter by hand, turn 3/4 to one full turn after the filter gasket contacts the filter base surface.
5. Re-install the filter guard with three 1/4”screws. Snug but do not over tighten.
6. Drain old oil filters of all free flowing oil prior to disposal. Place used oil in appropriate containers and deliver to an
approved recycling collection facility.
7. Remove the oil level check port plug from the transaxle prior to filling with oil. This will allow the transaxle to vent
during oil fill. Transaxle may be filled via port with a squeeze bottle or a jug pump.
9. Fill with
Mobil 1 Full Synthetic 15W50 Motor Oil** until oil just appears at the bottom of the oil level check port.
Install the oil level check port plug into transaxle. Snug but do not over tighten.
11. Proceed to the purge procedure.
12. Check oil level. Top off if necessary.
Transaxle service and maintenance
Transaxle Breather
**Warning: Use ONLY Mobil 1 Full Synthetic 15W50 Motor Oil and Newstripe Filter Part Number
10003778 in the transaxle of this machine.
Failure to use the correct filter and oil will cause damage to the transaxle and void the warranty.