page 32 — dca150ssju4f 60 hz generator • operation and parts manual — rev. #0 (11/06/14)
GeNeratOr start-Up prOCeDUre (MaNUaL)
Before starting
1. Place the
main, g.f.c.i., and aux.
circuit breakers
(Figure 35) in the
OFF
position prior to starting the
engine.
Figure 35. Main, Aux. and GFCI
Circuit Breakers (OFF)
2. Make sure the
voltage change-over board
has been
configured for the desired output voltage.
3. Connect the load to the
receptacles
or the
output
terminal lugs
as shown in Figure 10. These load
connection points can be found on the output terminal
panel and the output terminal panel’s hard wire hookup
panel.
4. Tighten terminal nuts securely to prevent load wires
from slipping out.
5. Close all engine enclosure doors (Figure 36).
Figure 36. Engine Enclosure Doors
caution
The engine’s exhaust contains harmful emissions.
alWaYs have adequate ventilation
when operating.
Direct exhaust away from nearby personnel.
Warning
never
manually start the engine with the
main, gfci
or auxiliary
circuit breakers in the
ON
(closed) position.
MAIN
CIRCUIT
BREAKER
GFCI
CIRCUIT
BREAKER
AUXILIARY
CIRCUIT
BREAKER
INCORRECT
CORRECT
starting (manual)
6. Place the
Auto-Off/Reset Manual Switch
in the
manual
position to start the engine (Figure 37).
Figure 37.
Auto-Off/Reset
Manual Switch
(Manual Position)
7. Once the engine starts, let the engine run for 1-2
minutes Let engine idle longer in cold weather
conditions. Listen for any abnormal noises. If any
abnormalities exist, shut down the engine and correct
the problem.
8. The generator’s frequency meter (Figure 38) should be
displaying the 60 cycle output frequency in
hertz.
Figure 38. Frequency Meter
NOTICE
If engine fails to start in a specified number attempts,
the shutdown lamp will illuminate and the Auto-Off/
Reset Switch must be placed in the Off/Reset position
before the engine can be restarted.
NOTICE
Engine will pre-heat automatically in cold weather
conditions." Glow Plug Hold " message will be displayed
and the engine will start automatically after pre-heating..
Содержание Whisperwatt DCA150SSJU4F
